Total Complaints
2 filings
CHEVROLET KODIAK · model year
2006 CHEVROLET KODIAK
2 NHTSA complaints, and 5 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2006CHEVROLETKODIAK carries 2 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2006 KODIAK is power train:driveline:driveshaft with 1 filings, followed by service brakes (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 5 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 57 investigation files overlapping the 2006 KODIAK, and 2 remain open. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
2
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| POWER TRAIN:DRIVELINE:DRIVESHAFT | 1 |
| SERVICE BRAKES | 1 |
Recalls (5)
07V38500028/08/2007
PARKING BRAKE
ON CERTAIN STRAIGHT TOWING OR NON-TOWING TRUCKS EQUIPPED WITH BENDIX AIR BRAKES, THE AIR BRAKE PARK CONTROL VALVE MAY DEVELOP EITHER AN INTERNAL AIR LEAK OR AN AIR RESTRICTION. THE PARK BRAKE MAY NOT RELEASE OR MAY RELEASE ONLY PARTIALLY.
06V31100016/08/2006
SERVICE BRAKES, AIR
CERTAIN TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS." AN INTERNAL CONTROL AND CHECK VALVE WITHIN THE AIR BRAKE APPLICATION VALVE ASSEMBLY WAS CONFIGURED IMPROPERLY, PREVENTING AIR FROM FLOWING THROUGH THE BRAKE SYSTEM AS DESIGNED.
06V25400013/07/2006
PARKING BRAKE:CONVENTIONAL:AIR
CERTAIN MEDIUM DUTY TRUCKS EQUIPPED SR-7 BENDIX BRAKE VALVES, THE CHECK VALVE INSIDE THE VALVE CAVITY MAY NOT PROPERLY SET, CAUSING INTERNAL AIR LEAKAGE. IF THE CHECK VALVE DOES NOT PROPERLY SEAT, THE RESULTING LEAKAGE CAN CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AF
07V46900004/10/2007
STEERING
ON CERTAIN MEDIUM DUTY TRUCKS EQUIPPED WITH ZF MODEL 8018 STEERING GEARS, THE STEERING GEAR MAY HAVE BEEN PRODUCED INCORRECTLY. A STEERING GEAR WITH THIS CONDITION MAY PRODUCE THE FEELING OF HITTING A CURB AND A CRACKING OR PINGING SOUND WHEN THE STEERING WHEEL IS TURNED.
06V28900003/08/2006
ENGINE AND ENGINE COOLING
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Recent Complaints
20131016SERVICE BRAKES
TL* THE CONTACT OWNS A 2006 CHEVROLET KODIAK. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, A STRANGE NOISE WAS HEARD FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE CALIPER BRACKETS HAD BECOME DETACHED FROM THE VEHICLE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 10,000. UPDATED 11/19/13*LJ
Mileage: 10,000
20060727POWER TRAIN:DRIVELINE:DRIVESHAFT
DT*: THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE DRIVESHAFT DETACHED FROM THE VEHICLE. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD, AND WAS THEN TAKEN TO A SERVICE DEALER. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE PROBLEM. UPDATED 10/04/06. *JB
Mileage: 24,000
Compare 2006CHEVROLETKODIAK to Similar Vehicles
NHTSA Investigations 2 Open
EA25007Engineering AnalysisOpen
Loss of motive power due to engine failure
PE23022Preliminary EvaluationClosed
Loss of Motive Power due to the Battery Energy Control Module
PE20016Preliminary EvaluationClosed
Electric Vehicle Battery Fires
EA20002Engineering AnalysisClosed
Outboard Front Seat Belt Anchor Cable Failure
PE20011Preliminary EvaluationClosed
Fuel Line Leak
Frequently Asked Questions
How many complaints does the 2006 CHEVROLET KODIAK have?▼
The 2006 CHEVROLET KODIAK has 2 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2006 CHEVROLET KODIAK?▼
Yes, the 2006 CHEVROLET KODIAK has 5 recall(s). The most common affected component is PARKING BRAKE. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2006 CHEVROLET KODIAK?▼
The most-complained component for the 2006 CHEVROLET KODIAK is POWER TRAIN:DRIVELINE:DRIVESHAFT with 1 complaints. Other frequently reported areas include SERVICE BRAKES.
Is the 2006 CHEVROLET KODIAK safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.