2012 CHEVROLET EXPRESS

EQUIPMENT

General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, and GMC Savana vehicles, equipped with certain Plastic-Handle Fire Extinguishers or Push Button 'Pin

STEERING:GEAR BOX:SHAFT PITMAN

GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET EXPRESS AND SUBURBAN VEHICLES, AND GMC SAVANA AND YUKON XL HEAVY DUTY VEHICLES. THE STEERING GEAR PITMAN SHAFT MAY NOT HAVE BEEN ADEQUATELY HARDENED AND COULD FRACTURE.

AIR BAGS:FRONTAL

General Motors LLC (GM) is recalling certain model year 2009-2014 Chevrolet Express and GMC Savana vans manufactured January 27, 2009, through March 7, 2014 with a gross vehicle weight rating of 10,000 pounds and less and equipped with front passenger air bags. In the affected vehicles, during a fr

FUEL SYSTEM, OTHER

General Motors LLC (GM) and IMPCO Automotive Division of IMPCO Technologies, Inc. (IMPCO) are recalling certain model year 2011-2013 Chevrolet Express and GMC Savana Cargo vans that have a compressed natural gas (CNG) fuel system installed as original equipment by IMPCO. The fuel systems, manufactu

FUEL SYSTEM, OTHER

General Motors LLC (GM) is recalling certain model year 2011-2014 Chevrolet Express compressed natural gas (CNG)vehicles manufactured September 10, 2010, to April 28, 2014, and GMC Savana CNG vehicles manufactured May 23, 2011, to April 21, 2014. The affected vehicles may leak natural gas from the

AIR BAGS

GM IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET EXPRESS AND GMC SAVANA VEHICLES MANUFACTURED FROM JUNE 2, 2011, THROUGH OCTOBER 17, 2011. THE SECOND STAGE OF THE DUAL-STAGE AIR BAG WILL NOT INFLATE IN A SEVERE FRONTAL IMPACT. ACCORDINGLY, THE AIR BAGS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDER

About 6:45 in the morning on November 10th, the vehicle was in a high-speed. Front end collision with adult cow elk at 70 miles an hour on the freeway, and the airbags failed to deploy in the Van on both front seats and the vehicle was severely damaged. Injuries were sustained.

Vehicle is upfitted as a school bus. Forward fuel tank strap failed in operation. Our company operates more than 100 of these vehicles and we experience a failure of fuel tank straps at a rate of about one vehicle per month. If the 2nd strap would also fail the gasoline tank would become dislodged and present a re hazard. This is even more critical as these vehicles are carrying students as a school bus. We perform visual inspections of the straps at 6 month intervals (per Pennsylvania these vehicles are subject to Semi-Annual State Inspection). There were no symptoms of the problem before this failure. There are never symptoms of the problem.

Vehicle is upfitted as a school bus. Forward fuel tank strap failed in operation. Our company operates more than 100 of these vehicles and we experience a failure of fuel tank straps at a rate of about one vehicle per month. If the 2nd strap would also fail the gasoline tank would become dislodged and present a fire hazard. This is even more critical as these vehicles are carrying students as a school bus. We perform visual inspections of the straps at 6 month intervals (per Pennsylvania these vehicles are subject to Semi-Annual State Inspection). There were no symptoms of the problem before this failure. There are never symptoms of the problem before any failure. Failed fuel tank straps on this were repaired by GM Dealer (Faulkner GMC, 705 Auto Park Blvd, West Chester, PA 19382) (Invoice #677658 - Invoice Date Feb 25 2025).

UNKNOWN...THE VEHICLE VEARED OFF ROAD AN INTO ON COMING TRAFFIC. Did not seam like steering was working properly. The final out come there were 2 deceased operators. In 2 different vehicles. I'm not sure if the recalls were ever repaired.

UNKNOWN...THE VEHICLE VEARED OFF ROAD AN INTO ON COMING TRAFFIC. Did not seam like steering was working properly. The final out come there were 2 deceased operators. In 2 different vehicles. I'm not sure if the recalls were ever repaired.

UNKNOWN...THE VEHICLE VEARED OFF ROAD AN INTO ON COMING TRAFFIC. Did not seam like steering was working properly. The final out come there were 2 deceased operators. In 2 different vehicles. I'm not sure if the recalls were ever repaired.

VEHICLE ROLLS WHILE IN PARK

Mileage: 85,000

I MANAGE A FLEET OF 53 SCHOOL BUSES, MODEL YEARS RANGING FROM 2008 TO 2015. I HAVE NOTICED A TREND WITH THE HYDRO BOOSTERS AND MASTER CYLINDERS, THEY TEND TO LEAK INTERNALLY ON THESE GM VEHICLES SOME HAVE BEGUN TO LEAK AS EARLY AS 30,000 MILES. I EXPECT TO HAVE TO REPLACE ALL OF THESE COMPONENTS, ON EVERY BUS IN THE NEAR FUTURE. AS THE FLEET AGES THE TREND IS GETTING INCREASINGLY WORSE. I BELIEVE THIS IS A DANGEROUS SITUATION BECAUSE I AM VIGILANT WITH KEEPING UP ON THIS ISSUE, HOWEVER I AM NOT SURE THAT THE GENERAL PUBLIC WILL HAVE THE SAME UNDERSTANDING ABOUT THE DANGER OF THIS DESIGN FLAW. I HAVE HAD BUSES COME IN BLEEDING BRAKE FLUID OR HYDRAULIC FLUID.

Mileage: 30,000

THE ENGINE WILL GO TO LOW POWER AND NOT GO MORE THAN 30 MPH WITHOUT WARNING. THIS IS AN AMBULANCE CHASSIS AND IS A KNOW PROBLEM GM HAS NOT ADDRESSED YET IN THE 2012 AND 2013 CHASSIS. IT CAN DO THIS ON HWYS WITH SPEED LIMITS OF 55, 65, 70 MPH SUDDENLY WHICH COULD CAUSE AN ACCIDENT AS NO STOP LIGHTS GIVE ANY WARNING AND YOU CAN'T SPEED UP ANYTIME IN POOR VISIBILITY OR AT ANYTIME. NOT ONLY IS IT BAD FOR THE INJURED OR ILL PATIENT IT COULD CAUSE AN ACCIDENT AND INJURY OTHERS. GM HAS FIXED THIS ON THE 2014 AND NEWER MODELS BUT NOT 12 &13. THIS IS NOT JUST OUR ONE UNIT THIS IS 2012 AND 2013 CHEVY DIESELS AMBULANCE ALL OVER THE US. WE HAVE FOUR UNITS THAT IT CAN HAPPEN TO AND TWO THAT IS HAS WITH PATIENTS. I HAVE CONTACTED THE EPA, GM, AND OUR INDIANA STATE SENATORS TRYING TO GET THIS DANGEROUS SITUATION TAKEN CARE OF IN THE LAST FEW DAYS. I AM ASKING ANYONE WHO WILL LISTEN TO HELP PUSH GM FOR A FIX.

Mileage: 100,000

THE ENGINE WILL GO TO LOW POWER AND NOT GO MORE THAN 30 MPH WITHOUT WARNING. THIS IS AN AMBULANCE CHASSIS AND IS A KNOW PROBLEM GM HAS NOT ADDRESSED YET IN THE 2012 AND 2013 CHASSIS. IT CAN DO THIS ON HWYS WITH SPEED LIMITS OF 55, 65, 70 MPH SUDDENLY WHICH COULD CAUSE AN ACCIDENT AS NO STOP LIGHTS GIVE ANY WARNING AND YOU CAN'T SPEED UP ANYTIME IN POOR VISIBILITY OR AT ANYTIME. NOT ONLY IS IT BAD FOR THE INJURED OR ILL PATIENT IT COULD CAUSE AN ACCIDENT AND INJURY OTHERS. GM HAS FIXED THIS ON THE 2014 AND NEWER MODELS BUT NOT 12 &13. THIS IS NOT JUST OUR ONE UNIT THIS IS 2012 AND 2013 CHEVY DIESELS AMBULANCE ALL OVER THE US. WE HAVE FOUR UNITS THAT IT CAN HAPPEN TO AND TWO THAT IS HAS WITH PATIENTS. I HAVE CONTACTED THE EPA, GM, AND OUR INDIANA STATE SENATORS TRYING TO GET THIS DANGEROUS SITUATION TAKEN CARE OF IN THE LAST FEW DAYS. I AM ASKING ANYONE WHO WILL LISTEN TO HELP PUSH GM FOR A FIX.

Mileage: 100,000

ENGINE WAS AT IDLE HAD PULLED INTO GAS STATION . ALARMS WENT OFF CHECK ENGINE LIGHT CAME ON, STABLE TRACK ERROR, MULTIPLE TONES. AFTER 20 SECONDS ENGINE STALLED. WOULD NOT CRANK. AFTER TALKING TO PEOPLE AND COUPLE TRIES FIX TOOK TO DEALERSHIP AS IT WAS DIAGNOSED TO BE THE ENGINE CONTROL MODULE SHORTED. I HAD GONE THRU RAIN EARLIER AND A COUPLE STORMS PASSED THRU WHILE AT STATION AND EATING. DEALER REPLACED ENGINE CONTROL MODULE AND PROGRAMMED IT. THIS COULD OF HAPPENED WHILE DRIVING AND WOULD OF LOST ENGINE POWER AND POWER STEERING. SINCE JUST MODULE REPLACED AND BEN TOLD IT IS KNOW TO SHORT OUT WHEN WET IT COULD HAPPEN AGAIN.

Mileage: 212,000

TL* THE CONTACT OWNS A 2012 CHEVROLET EXPRESS. WHEN THE BRAKES WERE DEPRESSED AND RELEASED, THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE CONTACT MENTIONED THAT THE STABILITRAK ACTIVATED INDEPENDENTLY AFTER BEING TURNED OFF WITHOUT WARNING. THE VEHICLE WAS TAKEN TO DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 47,000.

Mileage: 47,000

TL* THE CONTACT OWNS A 2012 CHEVROLET EXPRESS. WHEN THE BRAKES WERE DEPRESSED AND RELEASED, THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE CONTACT MENTIONED THAT THE STABILITRAK ACTIVATED INDEPENDENTLY AFTER BEING TURNED OFF WITHOUT WARNING. THE VEHICLE WAS TAKEN TO DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 47,000.

Mileage: 47,000

DRIVER'S SEAT BELT REEL SEIZED WHILE THE VEHICLE WAS PARKED SO THE BELT COULD NOT BE EXTENDED AND BUCKLED. THE OPERATOR WAS NOT ABLE TO WEAR THE SEAT BELT AS REQUIRED BY LAW. VEHICLE WAS BROUGHT TO THE CHEVROLET DEALER AND REPAIRED UNDER TSB 05-09-40-002G TODAY, A SECOND VEHICLE OF THE SAME MAKE/MODEL 2014 MODEL YEAR EXPERIENCED THE SAME PROBLEM.

Mileage: 4,750

PARKING BRAKE CABLE FOUND RUBBING ON THE HYDRAULIC SERVICE BRAKE LINE, FORWARD OF THE REAR AXLE ON DRIVERS SIDE OF CHASSIS. WEAR IS EVIDENT ON HYDRAULIC SERVICE BRAKE LINE AND PARKING CABLE, ALONG WITH COMPONENT PARKING BRAKE ASSEMBLY WAS STUCK UNDER. *TR

Mileage: 14,500

PARKING BRAKE CABLE FOUND RUBBING ON THE HYDRAULIC SERVICE BRAKE LINE, FORWARD OF THE REAR AXLE ON DRIVERS SIDE OF CHASSIS. WEAR IS EVIDENT ON HYDRAULIC SERVICE BRAKE LINE AND PARKING CABLE, ALONG WITH COMPONENT PARKING BRAKE ASSEMBLY WAS STUCK UNDER. *TR

Mileage: 14,500

PARKING BRAKE CABLE FOUND RUBBING ON THE HYDRAULIC SERVICE BRAKE LINE, FORWARD OF THE REAR AXLE ON DRIVERS SIDE OF CHASSIS. WEAR IS EVIDENT ON HYDRAULIC SERVICE BRAKE LINE AND PARKING CABLE, ALONG WITH COMPONENT PARKING BRAKE ASSEMBLY WAS STUCK UNDER. *TR

Mileage: 14,500

VIOLENT SHAKING WHILE APPLYING BRAKES. *TR

Mileage: 200