2008 CHEVROLET EXPRESS

POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

GM IS RECALLING 151 MY 2008 CHEVROLET EXPRESS AND GMC SAVANA VEHICLES EQUIPPED WITH ALL WHEEL DRIVE (AWD). SOME OF THESE VEHICLES HAVE TRANSFER CASES THAT WERE MANUFACTURED WITH AN INCORRECT PART THAT CAN CAUSE EARLY FAILURE OF A DRIVE CHAIN. IF THE CHAIN BREAKS, SHIFTING THE TRANSMISSION TO PARK

EQUIPMENT ADAPTIVE/MOBILITY

CUMMINGS IS RECALLING 42 MY 2006-2008 FORD E150, E350, CHEVROLET EXPRESS, MY 2006 FORD E250, GMC SAVANNA, DODGE SPRINTER CONVERSION VANS, AND MY 2007 NEWMAR DUTCHSTAR MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR V

EQUIPMENT ADAPTIVE/MOBILITY

CUMMINGS IS RECALLING 42 MY 2006-2008 FORD E150, E350, CHEVROLET EXPRESS, MY 2006 FORD E250, GMC SAVANNA, DODGE SPRINTER CONVERSION VANS, AND MY 2007 NEWMAR DUTCHSTAR MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR V

EQUIPMENT:APPLIANCE:AIR CONDITIONER

CUES, INC. IS RECALLING CERTAIN MODEL YEAR 2007-2009 SERVICE VEHICLES BUILT ON VARIOUS CHASSIS EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.

EQUIPMENT ADAPTIVE/MOBILITY

MAIN MOBILITY IS RECALLING CERTAIN CONVERSION VANS BUILT ON MODEL YEAR 2008-2010 CHEVROLET EXPRESS, 2009 GMC SAVANA, AND 2010 FORD TRANSIT CONNECT CHASSIS, AND FITTED WITH CERTAIN BRAUN WHEELCHAIR LIFTS. OVER TIME AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE WHEELCHAIR LIFT’S OUTER BARRIER M

FUEL SYSTEM, GASOLINE:STORAGE

GM IS RECALLING 567 MY 2008 CHEVROLET EXPRESS AND GMC SAVANA CUTAWAY VEHICLES WITH A 139" WHEEL BASE. THE FRAME RAIL ON THE DRIVER'S SIDE MAY BE WIDER THAN SPECIFICATION.

EQUIPMENT ADAPTIVE/MOBILITY

MAIN MOBILITY IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 CONVERSION VANS BUILT ON CHEVROLET EXPRESS AND GMC SAVANA CHASSIS FROM OCTOBER 2007 THROUGH MAY 2010 AND FITTED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "

POWER TRAIN:AUTOMATIC TRANSMISSION

GM IS RECALLING 2,481 MY 2008 CHEVROLET EXPRESS AND GMC SAVANA G-CUTAWAY FLEET VAN EQUIPPED WITH A 6.0L (RPO LY6) V8 ENGINE, 4L80E (RPO MT1) TRANSMISSION, 4.10 (RPO GT5) AXLE AND 75 MPH GOVERNOR (RPO 9D7). THESE VEHICLES HAVE A CONDITION IN WHICH THE TRANSMISSION MAY BE DAMAGED DUE TO FIRST GEAR EN

EQUIPMENT ADAPTIVE/MOBILITY

MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD N

EQUIPMENT ADAPTIVE/MOBILITY

MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD N

2008 Chevrolet Express van stalled while driving. I was able to coast over to the highway's shoulder. Van restarted after a few attempts and I resumed driving towards a small town ahead. Van re-stalled in the town. Attendant at small garage said the van had diagnostic codes for the fuel system. I was able to idle the van to a Chevrolet dealership for servicing. The dealership diagnosed and replaced the Fuel Pump Driver Module (part 20759945) (aka: Chassis Electronic Control Module) 17-days later, for about $650. Why wasn't I given notice and serviced under GM Recall Bulletin 14515 or 14515B, which specifies my van and that exact part? The dealership said my van is not part of that recall. The NHTSA site says my van has no pending recalls. The problem is serious enough that the Recall Bulletin applies regardless of years or miles. Even if an affected vehicle came in for an oil change, it can't be released until 20759945 is replaced. Van now suffering from code for upset oxyg

2008 Chevrolet Express van stalled while driving. I was able to coast over to the highway's shoulder. Van restarted after a few attempts and I resumed driving towards a small town ahead. Van re-stalled in the town. Attendant at small garage said the van had diagnostic codes for the fuel system. I was able to idle the van to a Chevrolet dealership for servicing. The dealership diagnosed and replaced the Fuel Pump Driver Module (part 20759945) (aka: Chassis Electronic Control Module) 17-days later, for about $650. Why wasn't I given notice and serviced under GM Recall Bulletin 14515 or 14515B, which specifies my van and that exact part? The dealership said my van is not part of that recall. The NHTSA site says my van has no pending recalls. The problem is serious enough that the Recall Bulletin applies regardless of years or miles. Even if an affected vehicle came in for an oil change, it can't be released until 20759945 is replaced. Van now suffering from code for upset oxyg

TOTAL BRAKE FAILURE. BRAKE LINE COMPLETELY RUSTED THROUGH WENT THROUGH A INTERSECTION AT 50 MPH NO BRAKES

Mileage: 60,000

PASSENGER SEAT AIR BAG SENSOR HAS FAILED.

TL* THE CONTACT OWNS A 2008 CHEVROLET EXPRESS. WHILE DRIVING, THE TRANSMISSION DISENGAGED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENGINE CONTROL MODULE AND TRANSMISSION CONTROL MODULE NEEDED TO BE REPROGRAMMED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V313000 (POWER TRAIN). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 55,000. UPDATED 10/28/16*LJ THE CONSUMER STATED THE LOCAL DEALER REPROGRAMMED THE ECM AND TCM. UPDATED 11/02/16.*JB

Mileage: 55,000

TL* THE CONTACT OWNS A 2008 CHEVROLET EXPRESS. WHILE DRIVING, THE TRANSMISSION DISENGAGED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENGINE CONTROL MODULE AND TRANSMISSION CONTROL MODULE NEEDED TO BE REPROGRAMMED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V313000 (POWER TRAIN). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 55,000. UPDATED 10/28/16*LJ THE CONSUMER STATED THE LOCAL DEALER REPROGRAMMED THE ECM AND TCM. UPDATED 11/02/16.*JB

Mileage: 55,000

WHEN I WAS DRIVING IN MY LOCAL AREA,MY BRAKES STARTED TO GIVE OUT.IN ORDER TO STOP I NEEDED TO PRESS VERY HARD ON THE BRAKES TO STOP. NOT EASY TO DO.THE WARNING BRAKE INDICATOR LIGHT CAME ON.I TOOK IT TO A LOCAL AUTO REPAIR SHOP.THEY SAID THEY COULD NOT FIX IT.THE BRAKE LINE WAS THE ISSUE.THEY FILLED IT WITH BRAKE FLUID THEN I WAS ABLE TOO DRIVE IT TO THE DEALER WHO THEN REPAIRED THE LINE ,FOR 600 DOLLARS. MY QUESTION IS WERE THERE OTHER COMPLAINTS ABOUT THIS ISSUE.?IF MY KIDS WERE DRIVING THIS IT MIGHT HAVE BEEN A DIFFERENT STORY.THANK GOODNESS NO ONE WAS HURT. THERE WAS NO OTHER INDICATORS OF THIS ISSUE. *TR

Mileage: 103,880

MECHANIC TESTED FROM CANISTER TO FUEL TANK HAS SMALL LEAK, WHICH MAY RESULT TO ENGINE LIGHT ON. I WENT TO LOCAL AUTO MECHANIC SHOP SAN JOSE CA AND THERE ARE TWO CHEVY EXPRESS OF THE SAME FAILURE BEFORE ME. *TR

Mileage: 123,000

THE SIDE DOORS ON BOTH SIDES VERY HARD TO OPEN BECAUSE YOU CANNOT GREASE THEM, THE SUNROOF LEAKS ,BACK REAR DOORS HANDLES STOP WORKING, TOOK THESE PROBLEMS SEVERAL TIMES TO BE ADDRESS AND PAID FOR SOME OF THE WORK TO BE DONE TO NO AVAIL STILL HAVE THE PROBLEMS, I HAVE A SON THAT'S DISABLE AND ITS VERY DANGEROUS IF SOMETHING HAPPENS AND WE CANNOT GET HIM OUT THE DOORS, PLUS THE SUNROOF LEAKS SO BAD THAT ANYONE IN THE REAR WILL GET SOAK AGAIN PAID TO HAVE IT DONE BUT TO NO AVAIL. CALL GM BUT AGAIN NO HELP JUST WAS TOLD THEY KNEW ABOUT THE PROBLEM AND THAT'S WHY THEY CHANGE THE HINGES THIS YEAR, GRANTED I HAD THIS PROBLEM WITH THE HINGES ON A 2001 CHEVY 1500 EXPRESS BOTH VAN I PURCHASED NEW TO SAY I HAD THESE PROBLEMS WITHIN A FEW WEEKS OR MONTHS AFTER PURCHASE AND NO RECALL AND TO SAY THEY KNEW ABOUT THE PROBLEM. *TR

Mileage: 199

WHILE DRIVING DOWN THE ROAD AT APPROXIMATELY 50 MPH ALL WARNING LIGHTS ON THE DASH LIT UP, THE SPEEDOMETER CEASED TO FUNCTION, THE RADIO CUT OUT, THE AIRBAGS WERE REPORTING AS NONFUNCTIONAL, THE ABS SYSTEM WAS REPORTING NONFUNCTIONAL. TOOK VEHICLE TO LOCAL MECHANIC WHO SAID THE PROBLEM APPEARED TO BE CAUSED BY CORROSION ON THE ABS SENSOR AS WELL AS CORROSION ON THE POWER DISTRIBUTION CABLES INTO THE FUSE BOX. ACCORDING TO THE MECHANIC GM WAS AWARE OF THE PROBLEM, AS TECHNICAL BULLETINS DATING BACK TO AROUND 2005 WERE ISSUED. HE ALSO STATED SHOULD IT HAPPEN AT THE TIME OF AN ACCIDENT THE AIR BAGS WOULD LIKELY FAIL TO DEPLOY, AND THE PROBLEM IN GENERAL COULD LEAD TO THE POSSIBILITY OF A VEHICLE FIRE. ACCORDING TO HIM THE ENTIRE PROBLEM COULD HAVE BEEN AVOIDED BY THE MANUFACTURER IF THEY HAD MADE SURE THE CABLES WERE WRAPPED IN SHRINK TUBE-THUS ELIMINATING THE INTRODUCTION OF MOISTURE TO THE ELECTRICAL WIRES. *TR

Mileage: 73,000

WHILE DRIVING DOWN THE ROAD AT APPROXIMATELY 50 MPH ALL WARNING LIGHTS ON THE DASH LIT UP, THE SPEEDOMETER CEASED TO FUNCTION, THE RADIO CUT OUT, THE AIRBAGS WERE REPORTING AS NONFUNCTIONAL, THE ABS SYSTEM WAS REPORTING NONFUNCTIONAL. TOOK VEHICLE TO LOCAL MECHANIC WHO SAID THE PROBLEM APPEARED TO BE CAUSED BY CORROSION ON THE ABS SENSOR AS WELL AS CORROSION ON THE POWER DISTRIBUTION CABLES INTO THE FUSE BOX. ACCORDING TO THE MECHANIC GM WAS AWARE OF THE PROBLEM, AS TECHNICAL BULLETINS DATING BACK TO AROUND 2005 WERE ISSUED. HE ALSO STATED SHOULD IT HAPPEN AT THE TIME OF AN ACCIDENT THE AIR BAGS WOULD LIKELY FAIL TO DEPLOY, AND THE PROBLEM IN GENERAL COULD LEAD TO THE POSSIBILITY OF A VEHICLE FIRE. ACCORDING TO HIM THE ENTIRE PROBLEM COULD HAVE BEEN AVOIDED BY THE MANUFACTURER IF THEY HAD MADE SURE THE CABLES WERE WRAPPED IN SHRINK TUBE-THUS ELIMINATING THE INTRODUCTION OF MOISTURE TO THE ELECTRICAL WIRES. *TR

Mileage: 73,000

WHILE DRIVING DOWN THE ROAD AT APPROXIMATELY 50 MPH ALL WARNING LIGHTS ON THE DASH LIT UP, THE SPEEDOMETER CEASED TO FUNCTION, THE RADIO CUT OUT, THE AIRBAGS WERE REPORTING AS NONFUNCTIONAL, THE ABS SYSTEM WAS REPORTING NONFUNCTIONAL. TOOK VEHICLE TO LOCAL MECHANIC WHO SAID THE PROBLEM APPEARED TO BE CAUSED BY CORROSION ON THE ABS SENSOR AS WELL AS CORROSION ON THE POWER DISTRIBUTION CABLES INTO THE FUSE BOX. ACCORDING TO THE MECHANIC GM WAS AWARE OF THE PROBLEM, AS TECHNICAL BULLETINS DATING BACK TO AROUND 2005 WERE ISSUED. HE ALSO STATED SHOULD IT HAPPEN AT THE TIME OF AN ACCIDENT THE AIR BAGS WOULD LIKELY FAIL TO DEPLOY, AND THE PROBLEM IN GENERAL COULD LEAD TO THE POSSIBILITY OF A VEHICLE FIRE. ACCORDING TO HIM THE ENTIRE PROBLEM COULD HAVE BEEN AVOIDED BY THE MANUFACTURER IF THEY HAD MADE SURE THE CABLES WERE WRAPPED IN SHRINK TUBE-THUS ELIMINATING THE INTRODUCTION OF MOISTURE TO THE ELECTRICAL WIRES. *TR

Mileage: 73,000

TL* THE CONTACT OWNS A 2008 CHEVROLET EXPRESS. THE CONTACT WAS DRIVING 45 MPH WHEN THE EXTERIOR AND INTERIOR LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER SEVEN TIMES. THE DEALER STATED THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 12,000 AND THE CURRENT MILEAGE WAS 47,115.

Mileage: 12,000

WHILE MERGING ON THE EXPRESSWAY THE TRANSMISSION FAILED TO SHIFT OUT OF FIRST OR SECOND GEAR CAUSING HIGH ENGINE RPM'S . I HAD TO SHIFT INTO NEUTRAL AND BACK INTO DRIVE SEVERAL TIMES BUT IT STILL FAILED TO SHIFT INTO ANY GEAR. I HAD TO PUT ON FLASHERS ( HEAVY TRAFFIC ) AND MAKE MY WAY TO THE EMERGENCY LANE. WHEN I CAME TO A COMPLETE STOP AND SHIFTED BACK INTO DRIVE IT SHIFTED CORRECTLY. I HAVE HAD THIS PROBLEM FOR SEVERAL MONTHS TO PRESENT DATE. I TOOK THE VAN TO THE DEALERSHIP WHO SAID THEY COULD NOT REPLICATE THE PROBLEM AND THEIR WERE NO CODE REPORTS SO THEY COULD NOT FIX THE ISSUE. THIS IS STILL A VERY REAL DANGER FOR MY FAMILY ( SEVEN CHILDREN ) BECAUSE THIS MALFUNCTION OCCURS WHILE AT HIGH SPEEDS USUALLY WHILE ENTERING THE EXPRESSWAY. *TR

Mileage: 35,000

MY ROTORS KEEP WARPING AND ENDANGERING MY LIFE!!!!!!!!!!!!!!!! I AM ON MY FOURTH SET OF ROTORS IN 84,000 MILES!!!! AND ON TOP OF THAT I HAVE THE ORIGINAL BRAKE PADS. AS A MATTER OF FACT FROM 14,000 MI TO 94,000 MY BRAKE PADS HAVE NOT WORN AT ALL. I HAD TO CUT THE ROTORS AT 30,000, AND THEN AT 50,000 THEY WERE WARPED AND TOO THIN TO RESURFACE. I REPLACED THEM AGAIN. AT 80,000 I HAD TO HAVE THEM CUT BECAUSE THEY WERE WARPED. THEN AT 85,000 I HAD TO HAVE THEM REPLACED AGAIN BECAUSE THEY WERE WARPED. MY ROTORS GET TO HOT THAT WHEN I BRAKE, MY WHOLE STEERING COLUMN SHAKES AND THE VEHICLE SWERVES TO HARD THAT I CAN BARELY STAY WITHIN THE LINES ON THE INTERSTATE. I FEARED FOR MY LIFE. I HAVE TRIED TO HAVE CHEVY LOOK INTO THIS AND EVERY TIME THEY JUST SLAP NEW ROTORS ON AND SEND ME ON MY WAY. THEY GIVE A 12,000 MILE WARRANTY ON ROTORS AND THEY ARE WARPING IN HALF THAT TIME. CHEVY HAS HAD TO REPLACE THEM FOR FREE UNDER WARRANTY 3 TIMES AND I HAVE HAD TO PAY ONCE. I FEEL LIKE ALL THEY WANT TO

Mileage: 36,000

TL*THE CONTACT OWNS A 2008 CHEVROLET EXPRESS VAN. THE CONTACT WAS DRIVING AND CAME ACROSS A DARK ROAD. THE CONTACT WAS FORCED TO USE THE HIGH BEAMS AND WHEN THEY WERE TURNED ON, THEY CAUSED ALL OF THE EXTERIOR LIGHTS TO FAIL. THE CONTACT TURNED THE HEADLIGHTS ON AND OFF, BUT THE HIGH BEAMS NO LONGER WORKED. THE DEALER INSPECTED THE VEHICLE AND STATED THAT BOTH LIGHT BULBS FAILED. THE CONTACT WAS CONCERNED ABOUT THE FAILURE SINCE THEY WERE ABLE TO USE THE LOW BEAMS. THE LOW BEAM HEAD LIGHTS AND HIGH BEAM HEAD LIGHTS WERE IDENTICAL AND THE FAILURE OCCURRED IN BOTH. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 37405.

Mileage: 37,405

WHILE DRIVING VAN AT START OF RUSH HOUR TRAFFIC. AND NEED TO STOP AT TRAFFIC LIGHT. THE ROAD A HEAD OF ME MERGES FROM 3 LANE TO 2. WHEN LIGHT CHANGED I STEPPED ON PEDAL TO MERGE LEFT. AND GAS PEDAL STAYED TO FLOOR. I AM NOT SURE IF I STEPPED ON PEDAL A FEW TIMES TO GET IT UNSTUCK, AS I HAD MY FOOT ON BRAKE TO SLOW VAN DOWN. I AM NOT SURE OF THE SEQUENCE. BUT VAN THEN STARTING TO SLOW DOWN. ALL THIS HAPPEN IN UNDER A MINUTE. IF IT HAD NOT SLOWED DOWN I WOULD OF RAN IN TO THE BACK OF CAR IN FRONT OF ME. IT WAS VERY SCARY. SINCE THEN PEDAL HAS WORKED FINE. I REPORTED THIS TO OUR MAIN OFFICE. AND TOLD THEM I WOULD TAKE IT TO A CHEVY DEALER TO HAVE IT LOOKED AT. ON 10-11-10 I TOOK IT TO DEALER AND THEY DIDN'T BELIEVE ME. BUT TOOK A QUICK LOOK AT PEDAL. AND SAID SAME THING AS TOYOTA "IT MUST OF BEEN FLOOR MAT. WE HAVEN'T SEEN OR HEARD OF THIS PROBLEM IN THIS VAN. VAN IS OUT OF WARRANTY. SPRING RETURN PRESSURE IS GOOD". I TOLD THEM I HAVE BEEN DRIVING FOR 40 YEARS AND THIS VAN FOR 2. AND NEV

Mileage: 44,950

2008 CHEVY 3500 EXPRESS VAN WITH ABOUT 40,000 MILES. HAVE A PROBLEM WITH THE STABILATRACK SYSTEM AND THE DEALER SAID IT IS A WIRING PROBLEM. IT IS A FLEET VAN. HAVE HAD THE PROBLEM ON 2 OF 15. TRANSMISSION DOWN SHIFTS WHEN THIS HAPPENS, SPEED IS LIMITED TO ABOUT 15 MPH, SPEEDOMETER QUITS. STABILATRACK LIGHT TURNS ON. *TR

Mileage: 40,000

2008 CHEVY 3500 EXPRESS VAN WITH ABOUT 40,000 MILES. HAVE A PROBLEM WITH THE STABILATRACK SYSTEM AND THE DEALER SAID IT IS A WIRING PROBLEM. IT IS A FLEET VAN. HAVE HAD THE PROBLEM ON 2 OF 15. TRANSMISSION DOWN SHIFTS WHEN THIS HAPPENS, SPEED IS LIMITED TO ABOUT 15 MPH, SPEEDOMETER QUITS. STABILATRACK LIGHT TURNS ON. *TR

Mileage: 40,000