Total Complaints
6 filings
CHEVROLET EXPRESS 1500 · model year
2007 CHEVROLET EXPRESS 1500
6 NHTSA complaints, 3 crash reports, and 1 active recall for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2007CHEVROLETEXPRESS 1500 carries 6 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 3 crashes, 1 fire, 12 injuries, and 1 fatality. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2007 EXPRESS 1500 is air bags with 2 filings, followed by power train:automatic transmission (1) and latches/locks/linkages (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 1 active recall campaign, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 57 investigation files overlapping the 2007 EXPRESS 1500, and 2 remain open. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
6
Complaints
3
Crashes
1
Fires
12
Injuries
1
Deaths
Crashes Reported
3 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| AIR BAGS | 2 |
| POWER TRAIN:AUTOMATIC TRANSMISSION | 1 |
| LATCHES/LOCKS/LINKAGES | 1 |
| ENGINE AND ENGINE COOLING | 1 |
| SERVICE BRAKES | 1 |
Recalls (1)
07V34200007/08/2007
EXTERIOR LIGHTING:BRAKE LIGHTS
CERTAIN VANS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." WHEN THE BRAKES ARE APPLIED, THE STOP LAMPS WILL ILLUMINATE. WHEN THE BRAKE PEDAL IS RELEASED, THE STOP LAMPS ARE NO LONGER ILLUMINATED BUT THE
Recent Complaints
20151214CrashSERVICE BRAKES
TL* THE CONTACT OWNS A 2007 CHEVROLET EXPRESS 1500. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOOR BOARD. AS A RESULT, THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT AND OTHER DRIVER SUSTAINED WHIP LASH. NO MEDICAL ATTENTION WAS REQUIRED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HYDRAULIC BRAKE LINE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT ALSO MENTIONED THAT HE FELT LIKE THE INSTALLATION OF THE BRAKE LINING WAS FAULTY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 58,000. UPDATED 04/08/16*LJ UPDATED 05/10/18 *JB *TR
Mileage: 58,000
20151214CrashAIR BAGS
TL* THE CONTACT OWNS A 2007 CHEVROLET EXPRESS 1500. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOOR BOARD. AS A RESULT, THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT AND OTHER DRIVER SUSTAINED WHIP LASH. NO MEDICAL ATTENTION WAS REQUIRED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HYDRAULIC BRAKE LINE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT ALSO MENTIONED THAT HE FELT LIKE THE INSTALLATION OF THE BRAKE LINING WAS FAULTY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 58,000. UPDATED 04/08/16*LJ UPDATED 05/10/18 *JB *TR
Mileage: 58,000
20111118ENGINE AND ENGINE COOLING
RADIATOR HOSE GETS DAMAGED WHEN RADIATOR FAN SHROUD TOUCHES IT REPEATEDLY THROUGH MOTOR VIBRATIONS. WE HAVE SEEN THIS ON TWO DIFFERENT VEHICLES (2007 AND 2010 MODELS) OF CHEVY EXPRESS VANS. 2010 VAN IS VIN #[XXX]. OUR MECHANIC EXPLAINED THIS TO US AND TOOK PHOTOS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
20091130LATCHES/LOCKS/LINKAGES
REAR SIDE DOORS ON MY CHEVROLET EXPRESS VAN HAVE CORRODED TO THE POINT THEY WILL NOT OPEN. *TR
Mileage: 31,669
20070730CrashFatalAIR BAGS
TL*THE CONTACT OWNS A 2007 CHEVROLET EXPRESS 1500. THE CONTACT STATED THAT THE AIR BAGS WERE DEFECTIVE. HIS VEHICLE WAS STRUCK FROM THE REAR WHILE IT WAS PARKED AND THE AIR BAGS FAILED TO DEPLOY. THE DRIVER WHO CRASHED INTO HIM WAS KILLED. FOUR PEOPLE WERE INJURED IN THE CONTACT'S VEHICLE AND FOUR PEOPLE WERE INJURED IN THE OTHER VEHICLE. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE MANUFACTURER ISSUED THE CONTACT A CASE NUMBER, HOWEVER, THEY DID NOT EXPLAIN WHY THE AIR BAGS DID NOT DEPLOY AND IF THE VEHICLE WAS INCLUDED IN ANY RECALLS. THE SPEED OF THE OTHER VEHICLE AT THE TIME OF THE CRASH WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 2,800.
Mileage: 2,800
20070416FirePOWER TRAIN:AUTOMATIC TRANSMISSION
TL*THE CONTACT OWNS A 2007 CHEVROLET EXPRESS 1500. ON A DRY DAY THE CONTACT HEARD METAL SCRAPING THE ROAD WHILE DRIVING 65 MPH. THE VEHICLE WAS PULLED OVER, AND THE CONTACT DISCOVERED THAT SPARKS WERE IGNITING FROM UNDERNEATH THE VEHICLE. THE CONTACT DIALED 911, AND THE VEHICLE WAS TOWED TO THE DEALER, (PATRICK CHEVROLET, WHERE IT REMAINED. THE FAILURE WAS DIAGNOSED AS THE TRANSMISSION. THE CONTACT CALLED THE MANUFACTURER, AND FILED A COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE 2,300.*AK
Mileage: 2,300
Compare 2007CHEVROLETEXPRESS 1500 to Similar Vehicles
NHTSA Investigations 2 Open
EA25007Engineering AnalysisOpen
Loss of motive power due to engine failure
PE23022Preliminary EvaluationClosed
Loss of Motive Power due to the Battery Energy Control Module
PE20016Preliminary EvaluationClosed
Electric Vehicle Battery Fires
EA20002Engineering AnalysisClosed
Outboard Front Seat Belt Anchor Cable Failure
PE20011Preliminary EvaluationClosed
Fuel Line Leak
Frequently Asked Questions
How many complaints does the 2007 CHEVROLET EXPRESS 1500 have?▼
The 2007 CHEVROLET EXPRESS 1500 has 6 NHTSA complaints, 3 crashes, 1 fires, 12 injuries, and 1 deaths reported.
Are there any recalls for the 2007 CHEVROLET EXPRESS 1500?▼
Yes, the 2007 CHEVROLET EXPRESS 1500 has 1 recall(s). The most common affected component is EXTERIOR LIGHTING:BRAKE LIGHTS. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2007 CHEVROLET EXPRESS 1500?▼
The most-complained component for the 2007 CHEVROLET EXPRESS 1500 is AIR BAGS with 2 complaints. Other frequently reported areas include POWER TRAIN:AUTOMATIC TRANSMISSION and LATCHES/LOCKS/LINKAGES.
Is the 2007 CHEVROLET EXPRESS 1500 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.