2023 CHEVROLET CORVETTE

FUEL SYSTEM, GASOLINE

General Motors, LLC (GM) is recalling certain 2023–2026 Chevrolet Corvette vehicles equipped with a left-side radiator/fan combination. Excess fuel may spill into the vehicle fuel-filler pocket during refueling and leak onto an ignition source.

Brake system failure, ESC shutdown, Speed-limited limp mode.

The contact owns a 2023 Chevrolet Corvette. The contact received notification of NHTSA Campaign Number: 25V536000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure.

On 10/13 after refuling my 2023 Chevy Corvette. I was cruising on a freeway when the car started showing signs of staying in 5th gear. The rev limiter was going from 500 to 2500 rpm rhythmically at a cruising speed of 65mph. At this time, I noticed the loss of response from the gas pedal. The car was then placed in manual shifting mode so that i can attempt to regain population control and maintain the flow of traffic as this was a high crash area. Unfortunately, this attempt did not work and the dash cluster illuminated with the following alerts "rear axil system offline" "idle creep disabled," "service transmission" at this time. The gear indicator on the dash that shows the mode and gear, for example: D3 (drive 3rd gear), completely disappeared and the gas pedal completely went unresponsive. At this point i used the momentum of the car in motion to exit off of the freeway into a parking center. The vehicle proceeded to not respond in regards to going into park, reverse, or drive. Th

On 10/13 after refuling my 2023 Chevy Corvette. I was cruising on a freeway when the car started showing signs of staying in 5th gear. The rev limiter was going from 500 to 2500 rpm rhythmically at a cruising speed of 65mph. At this time, I noticed the loss of response from the gas pedal. The car was then placed in manual shifting mode so that i can attempt to regain population control and maintain the flow of traffic as this was a high crash area. Unfortunately, this attempt did not work and the dash cluster illuminated with the following alerts "rear axil system offline" "idle creep disabled," "service transmission" at this time. The gear indicator on the dash that shows the mode and gear, for example: D3 (drive 3rd gear), completely disappeared and the gas pedal completely went unresponsive. At this point i used the momentum of the car in motion to exit off of the freeway into a parking center. The vehicle proceeded to not respond in regards to going into park, reverse, or drive. Th

My fiancé, [XXX] died on [XXX], while driving his 2023 Chevrolet Corvette Z06 Convertible . He was passing another car on a straight road ,A witness confirmed he was not speeding excessively. Suddenly, he lost control of the vehicle, crashed, and the car burst into flames. I’ve since learned that GM issued a recall for this model due to fuel spillage and fire risk. Other owners have reported transmission and instrument panel failures. I believe a defect in the vehicle may have caused or contributed to [XXX] ’s death. I am requesting a formal investigation into this incident and the safety of the 2023 Corvette Z06. I am also pursuing legal action to hold GM accountable. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Shortly after purchasing the vehicle at the local Carson City,NV CHEVROLET dealer on 5/18/2025 my passenger started to hear a muffled “thumping noise” from the right front foot well? I am a disabled veteran USAF pilot with hearing loss and did not immediately hear it. The car had 29,129 miles on it when purchased and was a “certified vehicle” with some remaining original warranty as well as an extended warranty given its great condition(I was told!) After a few hundred miles of driving the sound became much louder and VERY noticeable when even on rough roads I discovered when removing the “frunk” trim to investigate a weak battery up front that an aluminum upper suspension right front shock mount was only being retained by a single bolt of the FOUR designed to secure it! Two had sheared the aluminum mount off and one bolt had broken off and was missing! The car has been in possession of the dealer since I had it towed in 6/27/2025 I have had NO RESPONSE from the dealer as t

On 8/3/2025 I was at a stop light. It turned green. I went to go and my car would not go past first gear. Had to pull over. Waited turned the car off. Turned it back on and started driving, then I got an alert 545. Then my entire screen went blank only showing the alert. I called my dealership to explain. They said there were recalls on the 2023 and 2024 transmissions. That’s why I got the alert 545. But they said there was nothing they could do. I could bring it in for a test drive with a technician and if it pops up alert 545 then they would submit a ticket to GM. But the earliest to fix my corvette would be October. But also saying I would have to pay full price for everything. I bought my 2023 Corvette 1LT C8 stingray in 2022 and have only put 19,000 miles on it. I do not miss maintenance or anything. I’m not sure how to get GM to pay for my transmission and labor. It also would not let me acknowledge and click the button on the steering wheel. My display went off and I could n

The passenger seat belt locks and pins the passenger down. It will not release unless it’s released from the release button. If there’s an accident, my passenger would be seriously injured.

When drive slowly, sometimes it grinds really lound when the wheels are wet or dry. Took it to 2 different dealers, they said it's normal. I have video for both incidents.

While I was on vacation in Gatlinburg TN my vehicle parked in my home garage turned on by itself producing carbon monoxide in my property I reached out numerous times to GM and they failed to do anything about it. I have footage please assist thanks.

On [XXX] I was driving my corvette in Atlantic City, New Jersey, which at that time I noticed smoke coming from the rear of the vehicle. I looked at my dash to see if any warning lights or check engine lights were on and nothing Indicate there was a problem. So I did continue to drive to get to a safe place where I can pull over and look at the engine. When I came up to the red light, the car next to me told me that my vehicle was on the fire. I was able to pull over on the side of road next to the hospital in Atlantic City. And then I got out of my car to nattempt to put out the fire myself as I noticed Melting Plastic that was on fire, was dripping all my tires to avoid the tires Catching on fire. I Remove the plastic that was on fire, causing burns to my hand. Then I called the fire to department to help me put out the fire. Once the fire was put out. I had it towed to the dealership they Told me to call my insurance company. Doing insurance process one of their technicians looked

Normal driving conditions while in Z-mode in moderate traffic, an audible bang was heard, however there was no immediate issue. A few minutes later the Check Engine Light, ABS, Traction Control and other lights appear on dash. Once lights appear, brakes fail and no longer slow the car down, the gas pedal only revved the car and could no longer accelerate. The car was still on and “driving”, I just didn’t have acceleration or brakes. I put my turn signal on and eventually was able to safely pull off the road and stop the vehicle utilizing Neutral and the Emergency Parking Brake. I was in genuine fear of crashing due to not having brakes or acceleration and felt that if the parking brake and/or neutral failed, then I’d have to crash to stop the vehicle. Not having brakes or acceleration put myself, my passenger, and every vehicle around me when it occurred at risk of injury. This has occurred twice in less than 1 year of ownership with this vehicle and I’ve taken it to two

Normal driving conditions while in Z-mode in moderate traffic, an audible bang was heard, however there was no immediate issue. A few minutes later the Check Engine Light, ABS, Traction Control and other lights appear on dash. Once lights appear, brakes fail and no longer slow the car down, the gas pedal only revved the car and could no longer accelerate. The car was still on and “driving”, I just didn’t have acceleration or brakes. I put my turn signal on and eventually was able to safely pull off the road and stop the vehicle utilizing Neutral and the Emergency Parking Brake. I was in genuine fear of crashing due to not having brakes or acceleration and felt that if the parking brake and/or neutral failed, then I’d have to crash to stop the vehicle. Not having brakes or acceleration put myself, my passenger, and every vehicle around me when it occurred at risk of injury. This has occurred twice in less than 1 year of ownership with this vehicle and I’ve taken it to two

Normal driving conditions while in Z-mode in moderate traffic, an audible bang was heard, however there was no immediate issue. A few minutes later the Check Engine Light, ABS, Traction Control and other lights appear on dash. Once lights appear, brakes fail and no longer slow the car down, the gas pedal only revved the car and could no longer accelerate. The car was still on and “driving”, I just didn’t have acceleration or brakes. I put my turn signal on and eventually was able to safely pull off the road and stop the vehicle utilizing Neutral and the Emergency Parking Brake. I was in genuine fear of crashing due to not having brakes or acceleration and felt that if the parking brake and/or neutral failed, then I’d have to crash to stop the vehicle. Not having brakes or acceleration put myself, my passenger, and every vehicle around me when it occurred at risk of injury. This has occurred twice in less than 1 year of ownership with this vehicle and I’ve taken it to two

Put vehicle in reverse. Vehicle would not move. Vehicle placed back in park. Put vehicle in reverse again; and after advanced acceleration heard a loud clunk sound and jarring movement. Car continued in reverse normally. Vehicle was put into drive and driven approximately 500 feet at which time vehicle shut down. Service transmission and “rear axle not engaged” messages showing, as well as an overheating message. Dealership unresponsive.

shot

shot

This is a 2023 Corvette 70th Anniversary Edition. Button to open door from drivers side doesn’t activate, needing to pull manual handle. Electric button to open hard top convertible doesn’t activate. Vehicle taken to dealer and inspected. According to inspection results, there is major components which controls these functions was ordered and received. Vehicle is at the dealer for repair.

The hood unexpectedly opens and can fly up and cause loss of forward vision. The hood can fly off and cause death. With no visibility the a collision can cause death.

The hood unexpectedly opens and can fly up and cause loss of forward vision. The hood can fly off and cause death. With no visibility the a collision can cause death.