Total Complaints
2 filings
CHEVROLET C7500 · model year
2006 CHEVROLET C7500
2 NHTSA complaints, and 2 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2006CHEVROLETC7500 carries 2 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2006 C7500 is structure:body:tailgate:hinge and attachments with 1 filings, followed by electrical system:12v/24v/48v battery (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 2 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 57 investigation files overlapping the 2006 C7500, and 2 remain open. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
2
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS | 1 |
| ELECTRICAL SYSTEM:12V/24V/48V BATTERY | 1 |
Recalls (2)
06V25400013/07/2006
PARKING BRAKE:CONVENTIONAL:AIR
CERTAIN MEDIUM DUTY TRUCKS EQUIPPED SR-7 BENDIX BRAKE VALVES, THE CHECK VALVE INSIDE THE VALVE CAVITY MAY NOT PROPERLY SET, CAUSING INTERNAL AIR LEAKAGE. IF THE CHECK VALVE DOES NOT PROPERLY SEAT, THE RESULTING LEAKAGE CAN CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AF
14V07000011/02/2014
ELECTRICAL SYSTEM
Monroe Truck Equipment (Monroe) is recalling certain model year 2006, 2008 and 2009 Chevrolet C7500 vehicles, 2005-2006 Chevrolet Tahoe vehicles, and 2009 Ford F-350, and F-450 vehicles, equipped with Sure Power-brand battery equalizers or DC-DC converters containing a particular epoxy sealing, aka
Recent Complaints
20071026STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
MONDAY, 10/15/07 VEHICLE WOULD NOT START IN THE A.M. VEHICLE WAS JUMPED STARTED PROCEEDED IMMEDIATELY TO DEALER. EXPLAINED TO SERVICE DEPT VEHICLE WOULD NOT START HOWEVER, ALL INTERIOR LIGHTS WERE WORKING BUT VEHICLE WOULD NOT START. SERVICE DEPT HAD VEHICLE ALL DAY COULD NOT FIND ANYTHING WRONG. BATTERY WAS CHECKED OUT IT WAS OK. MONDAY NIGHT (10/15/07) VEHICLE WOULD NOT START AFTER BEING IN SERVICE ALL DAY. VEHICLE WAS JUMPED STARTED AGAIN TO GET ME HOME. TUESDAY (10/16/07) AM VEHICLE STARTED WENT TO WORK. CHECKED VEH AROUND 10:30 AM VEHICLE WOULD NOT START. VEHICLE HAD TO BE JUMPED STARTED IMMEDIATELY WENT TO DEALERSHIP COMPLAINING OF THE PROBLEM. A DEVICE WAS PLACED IN VEHICLE CHECKING THE MILLA AMP DRAW. TRACED PROBLEM TO FAULTY GATE MODULE WAS DRAINING ON BATTERY (IN OTHER WORDS TERRORIZING BATTERY) PREVENTING VEHICLE FROM STARTING. CALLED GM CUSTOMER SERVICE TO COMPLAIN ABOUT BEING REIMBURSED. WORDS THAT WERE USED BY GM WERE MALFUNCTION, FAULTY PART. I STRONGLY FEE
Mileage: 40,577
20071026ELECTRICAL SYSTEM:12V/24V/48V BATTERY
MONDAY, 10/15/07 VEHICLE WOULD NOT START IN THE A.M. VEHICLE WAS JUMPED STARTED PROCEEDED IMMEDIATELY TO DEALER. EXPLAINED TO SERVICE DEPT VEHICLE WOULD NOT START HOWEVER, ALL INTERIOR LIGHTS WERE WORKING BUT VEHICLE WOULD NOT START. SERVICE DEPT HAD VEHICLE ALL DAY COULD NOT FIND ANYTHING WRONG. BATTERY WAS CHECKED OUT IT WAS OK. MONDAY NIGHT (10/15/07) VEHICLE WOULD NOT START AFTER BEING IN SERVICE ALL DAY. VEHICLE WAS JUMPED STARTED AGAIN TO GET ME HOME. TUESDAY (10/16/07) AM VEHICLE STARTED WENT TO WORK. CHECKED VEH AROUND 10:30 AM VEHICLE WOULD NOT START. VEHICLE HAD TO BE JUMPED STARTED IMMEDIATELY WENT TO DEALERSHIP COMPLAINING OF THE PROBLEM. A DEVICE WAS PLACED IN VEHICLE CHECKING THE MILLA AMP DRAW. TRACED PROBLEM TO FAULTY GATE MODULE WAS DRAINING ON BATTERY (IN OTHER WORDS TERRORIZING BATTERY) PREVENTING VEHICLE FROM STARTING. CALLED GM CUSTOMER SERVICE TO COMPLAIN ABOUT BEING REIMBURSED. WORDS THAT WERE USED BY GM WERE MALFUNCTION, FAULTY PART. I STRONGLY FEE
Mileage: 40,577
Compare 2006CHEVROLETC7500 to Similar Vehicles
NHTSA Investigations 2 Open
EA25007Engineering AnalysisOpen
Loss of motive power due to engine failure
PE23022Preliminary EvaluationClosed
Loss of Motive Power due to the Battery Energy Control Module
PE20016Preliminary EvaluationClosed
Electric Vehicle Battery Fires
EA20002Engineering AnalysisClosed
Outboard Front Seat Belt Anchor Cable Failure
PE20011Preliminary EvaluationClosed
Fuel Line Leak
Frequently Asked Questions
How many complaints does the 2006 CHEVROLET C7500 have?▼
The 2006 CHEVROLET C7500 has 2 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2006 CHEVROLET C7500?▼
Yes, the 2006 CHEVROLET C7500 has 2 recall(s). The most common affected component is PARKING BRAKE:CONVENTIONAL:AIR. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2006 CHEVROLET C7500?▼
The most-complained component for the 2006 CHEVROLET C7500 is STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS with 1 complaints. Other frequently reported areas include ELECTRICAL SYSTEM:12V/24V/48V BATTERY.
Is the 2006 CHEVROLET C7500 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.