Total Complaints
3 filings
CHEVROLET C5500 · model year
2007 CHEVROLET C5500
3 NHTSA complaints, and 6 active recalls for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2007CHEVROLETC5500 carries 3 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2007 C5500 is engine and engine cooling:exhaust system with 1 filings, followed by fuel/propulsion system (1) and engine (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability. This model year has 6 active recall campaigns, which means the manufacturer is obligated to remedy the covered defect at no charge for the life of the vehicle — the full NHTSA campaign numbers are listed below.
NHTSA currently has 57 investigation files overlapping the 2007 C5500, and 2 remain open. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
3
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| ENGINE AND ENGINE COOLING:EXHAUST SYSTEM | 1 |
| FUEL/PROPULSION SYSTEM | 1 |
| ENGINE | 1 |
Recalls (6)
08V34400028/07/2008
TRAILER HITCHES
KNAPHEIDE IS RECALLING 108 MY 2006-2008 PRO SERIES TRUCK BEDS EQUIPPED WITH AN ICC BUMPER WHICH INCLUDED A PROVISION FOR A BALL HITCH. THERE MAY BE AN INSUFFICIENT WELD ATTACHING THE HITCH CHANNEL TO THE SUPPORTING STRUCTURE.
09V45600019/11/2009
EQUIPMENT:APPLIANCE:AIR CONDITIONER
CUES, INC. IS RECALLING CERTAIN MODEL YEAR 2007-2009 SERVICE VEHICLES BUILT ON VARIOUS CHASSIS EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.
09V09100019/03/2009
ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
LDV IS RECALLING 81 TRUCKS BUILT ON CHEVROLET AND FORD MY 2007-2009 C5500, MY 2008-2009 W5500, AND MY 2008 F-650 CHASSIS SPECIFICALLY FOR SNAP-ON TOOLS FOR USE AS A MOBILE SUPPLY COMPANY. THERE MAY BE A CABLE INSTALLED ON THE BATTERY ISOLATOR WITH THE BODY OF THE CABLE LUG FACING THE ISOLATOR. WIT
07E08600016/10/2007
SUSPENSION
CERTAIN LINK ULTRARIDE REAR AIR SUSPENSION SYSTEMS, MODEL 8M000070, SOLD FOR INSTALLATION AS AFTERMARKET EQUIPMENT ON GM CHASSIS MODELS 4500 AND 5500, AMBULANCES AND SHUTTLE BUSES. THE AXLE SIDE LATERAL CONTROL BRACKET OF THE SUSPENSION HAS CRACKED IN SOME CASES.
12V58400012/12/2012
EQUIPMENT
Creative Bus Sales, Inc is recalling certain model year 2006-2011 Chevrolet and GMC C5500, and Ford E450, and Econoline 350 vehicles equipped with Braun wheelchair lifts. Over time, or with frequent use, the roll stop latches on the outer barrier of the lifts may become bent or misaligned.
08E00400007/01/2008
EQUIPMENT ADAPTIVE/MOBILITY
CERTAIN INTERMOTIVE WHEELCHAIR LIFT INTERLOCK, P/NO. ILIS605-H3 ILIS ACTIVATION KIT (INTERLOCK OPTION FOR GATEWAY 401) SOLD FOR USE AS AFTERMARKET FOR 2005 - 2008 CHEVY 560 (C4500 AND C5500 KODIAK) 6.6L DIESEL VEHICLES WHICH A PROTECTION DIODE WAS USED. THE DIODE CAN BE EXPOSED TO VOLTAGE SPIKES GR
Recent Complaints
20131211FUEL/PROPULSION SYSTEM
I BROUGHT A 2007 CHEVY C5500 WITH DURAMAX DIESEL BECAUSE IT WAS CAME WITH GREAT REVIEWS ONLY TO LEARN THAT THE FUEL SYSTEM IS KNOW TO BEST THE WORST AND THE MOST COMMON IS THE INJECTORS AND INJECTOR PUMP. THIS IS IN THE DURAMAX AND CAT MOTORS. THIS MOTOR HAS EFFECTIVE THE US CITIZENS FOR TO LONG. *TR
Mileage: 34,500
20131211ENGINE
I BROUGHT A 2007 CHEVY C5500 WITH DURAMAX DIESEL BECAUSE IT WAS CAME WITH GREAT REVIEWS ONLY TO LEARN THAT THE FUEL SYSTEM IS KNOW TO BEST THE WORST AND THE MOST COMMON IS THE INJECTORS AND INJECTOR PUMP. THIS IS IN THE DURAMAX AND CAT MOTORS. THIS MOTOR HAS EFFECTIVE THE US CITIZENS FOR TO LONG. *TR
Mileage: 34,500
20081215ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
TL*THE CONTACT OWNS A 2007 CHEVROLET C5500. THE VEHICLE WAS PURCHASED IN INDIANA. THE CONTACT SENT THE VEHICLE TO THE LIME LITE COACH DEALER IN CALIFORNIA FOR MODIFICATION. THE VEHICLE WAS RETURNED WITHOUT THE REGION SYSTEM EXTENSION PIPE (CATALYTIC CONVERTER); THEREFORE, IT FAILED INSPECTION. THE VEHICLE WAS REPAIRED. THE CONTACT STATED THAT THE VEHICLE WAS A 2008, BUT THE CARFAX REPORT INDICATED THE VIN WAS A 2007. THE CURRENT AND FAILURE MILEAGES WERE 18,000.
Mileage: 18,000
Compare 2007CHEVROLETC5500 to Similar Vehicles
NHTSA Investigations 2 Open
EA25007Engineering AnalysisOpen
Loss of motive power due to engine failure
PE23022Preliminary EvaluationClosed
Loss of Motive Power due to the Battery Energy Control Module
PE20016Preliminary EvaluationClosed
Electric Vehicle Battery Fires
EA20002Engineering AnalysisClosed
Outboard Front Seat Belt Anchor Cable Failure
PE20011Preliminary EvaluationClosed
Fuel Line Leak
Frequently Asked Questions
How many complaints does the 2007 CHEVROLET C5500 have?▼
The 2007 CHEVROLET C5500 has 3 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2007 CHEVROLET C5500?▼
Yes, the 2007 CHEVROLET C5500 has 6 recall(s). The most common affected component is TRAILER HITCHES. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2007 CHEVROLET C5500?▼
The most-complained component for the 2007 CHEVROLET C5500 is ENGINE AND ENGINE COOLING:EXHAUST SYSTEM with 1 complaints. Other frequently reported areas include FUEL/PROPULSION SYSTEM and ENGINE.
Is the 2007 CHEVROLET C5500 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.