Total Complaints
1 filings
CHEVROLET C4500 NA · model year
2008 CHEVROLET C4500 NA
1 NHTSA complaints, and 2 recall campaigns listed for this cohort. A VIN lookup is required to determine whether a specific vehicle has an unrepaired recall.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2008CHEVROLETC4500 NA carries 1 consumer safety complaint in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
The most frequently selected component label in reports for the 2008 C4500 NA is engine and engine cooling:exhaust system with 1 filings. Complaint categories reflect owner reports and intake categorization; they do not establish a defect pattern or cause. This cohort has 2 NHTSA recall campaigns listed below. Enter a VIN in NHTSA's official recall lookup to determine whether a specific vehicle has an unrepaired recall.
NHTSA currently has 57 investigation files overlapping the 2008 C4500 NA, and 2 remain open. Owners comparing this cohort against neighboring years should read the complaint-by-year trend as report volume, not a causal diagnosis. Use the related-complaint feed and the official recall lookup when researching a specific vehicle.
1
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| ENGINE AND ENGINE COOLING:EXHAUST SYSTEM | 1 |
Recalls (2)
09V45600019/11/2009
EQUIPMENT:APPLIANCE:AIR CONDITIONER
CUES, INC. IS RECALLING CERTAIN MODEL YEAR 2007-2009 SERVICE VEHICLES BUILT ON VARIOUS CHASSIS EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.
08E00400007/01/2008
EQUIPMENT ADAPTIVE/MOBILITY
CERTAIN INTERMOTIVE WHEELCHAIR LIFT INTERLOCK, P/NO. ILIS605-H3 ILIS ACTIVATION KIT (INTERLOCK OPTION FOR GATEWAY 401) SOLD FOR USE AS AFTERMARKET FOR 2005 - 2008 CHEVY 560 (C4500 AND C5500 KODIAK) 6.6L DIESEL VEHICLES WHICH A PROTECTION DIODE WAS USED. THE DIODE CAN BE EXPOSED TO VOLTAGE SPIKES GR
Recent Complaints
20100319ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
PROBLEM WITH ENGINE SHUTTING DOWN WITH NO WARNING. HAS HAPPENED COUNTLESS TIMES. HAS BEEN IN FOR REPAIR SEVERAL TIMES BUT PROBLEM STILL EXISTS. THE PROBLEM IS THE DIESEL PARTICULATE FILTER REGENERATION #PIP4598. IT SETS CODE 244B WHICH SHUTS THE ENGINE DOWN TO 2000 RPM MAX. THIS IS A SIGNIFICANT SAFETY ISSUE AS IT WILL SLOW TO A CRAWL IN TRAFFIC. ON 3/14 ON I-95 IN NEW YORK CITY, THE REGEN LIGHT RECURRED (CODE 244B). I COULD BARELY GET OUT OF TRAFFIC AND CAME CLOSE TO A SERIOUS ACCIDENT. *TR
Mileage: 212,000
Compare 2008CHEVROLETC4500 NA to Similar Vehicles
NHTSA Investigations 2 Open
EA25007Engineering AnalysisOpen
Loss of motive power due to engine failure
PE23022Preliminary EvaluationClosed
Loss of Motive Power due to the Battery Energy Control Module
PE20016Preliminary EvaluationClosed
Electric Vehicle Battery Fires
EA20002Engineering AnalysisClosed
Outboard Front Seat Belt Anchor Cable Failure
PE20011Preliminary EvaluationClosed
Fuel Line Leak
Frequently Asked Questions
How many complaints does the 2008 CHEVROLET C4500 NA have?▼
The 2008 CHEVROLET C4500 NA has 1 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
Are there any recalls for the 2008 CHEVROLET C4500 NA?▼
Yes, the 2008 CHEVROLET C4500 NA has 2 recall(s). The most common affected component is EQUIPMENT:APPLIANCE:AIR CONDITIONER. Recalls are issued by NHTSA and manufacturers must provide a free remedy.
What are the most common problems with the 2008 CHEVROLET C4500 NA?▼
The most-complained component for the 2008 CHEVROLET C4500 NA is ENGINE AND ENGINE COOLING:EXHAUST SYSTEM with 1 complaints. Other frequently reported areas include various components.
Is the 2008 CHEVROLET C4500 NA safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data vintage: August 2026. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Every figure on PlainCars is rendered directly from NHTSA complaint and safety data, no number is typed in by an editor. This year-specific record is rendered from NHTSA ODI, recall, and NCAP rows for the 2008 CHEVROLET C4500 NA; no figure is typed in by an editor. See our editorial standards & corrections policy, the methodology behind these numbers, or report a data error. Data current as of August 2026.
Read our methodology - how this data is sourced, computed, and verified.