2001 CHEVROLET ASTRO

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE D

FUEL SYSTEM, GASOLINE

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CE

EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

ON CERTAIN MINIVANS, THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT CONDITION IN THE STOP LAMP OR HAZARD LAMP CIRCUIT THAT RESULTS IN THE STOP LAMPS AND HAZARD LAMPS BEING INOPERATIVE.

VAN WILL NOT PASS SMOG. THE VERY LAST TIME I DROVE IT, I WAS DRIVING IT ON A CITY STREET AND IT JUST DIED OUT. I'VE SPENT HUNDREDS OF DOLLARS TO HAVE IT FIXED AND ITSTILL ISN'T FIXED TO PASS SMOG. A SHOP SAID MY FUEL INJECTION SPIDER SYSTEM IS BAD.

Mileage: 166,200

I AM A LICENSED CAR DEALER. I AM VERY CONCERNED AT WHAT I AM SEEING WITH MY CUSTOMERS, WITH CARS I SEE AT THE AUCTIONS, AND WITH BLOG SITES ON THE INTERNET CONCERNING CHEVY'S EBCM COMPUTER MODULE. AT THE AUCTIONS I AM SEEING AT LEAST 25% OF CHEVROLETS AND ABOUT 10% OF FORDS COMING THROUGH WITH BRAKE AND ABS LIGHTS ON. MY MAIN CONCERN IS WITH THE CHEVY'S EBCM. THESE VERY EXPENSIVE UNITS FAIL AT THE RELAY POINT ON THE PRINTED CIRCUIT BOARDS DUE TO BAD SOLDER JOINTS FROM THE FACTORY. WHEN THEY FAIL, THE DRIVER GETS A BRAKE LIGHT AND AN ABS INDICATOR LIGHT ON THE DASH. THE BRAKES STILL WORK ON THE CAR, BUT THEY DON'T WORK AS DESIGNED. IN FACT THE DRIVER GETS A FALSE SENSE OF SECURITY BECAUSE HIS CAR IS STOPPING, BUT IN A SLIPPERY SITUATION IT WILL NOT STOP AS DESIGNED. WHEN I WENT TO THE INTERNET FOR IDEAS TO FIX THE PROBLEM, I AM FINDING A LOT OF POSTINGS SAYING JUST TAKE THE BULB OUT OF THE DASH! I AM ALSO SEEING ADS ON E BAY WHERE YOU CAN SEND YOUR EBCM TO A REPAIR STATION, THEY TAKE IT

Mileage: 100,000

I AM A LICENSED CAR DEALER. I AM VERY CONCERNED AT WHAT I AM SEEING WITH MY CUSTOMERS, WITH CARS I SEE AT THE AUCTIONS, AND WITH BLOG SITES ON THE INTERNET CONCERNING CHEVY'S EBCM COMPUTER MODULE. AT THE AUCTIONS I AM SEEING AT LEAST 25% OF CHEVROLETS AND ABOUT 10% OF FORDS COMING THROUGH WITH BRAKE AND ABS LIGHTS ON. MY MAIN CONCERN IS WITH THE CHEVY'S EBCM. THESE VERY EXPENSIVE UNITS FAIL AT THE RELAY POINT ON THE PRINTED CIRCUIT BOARDS DUE TO BAD SOLDER JOINTS FROM THE FACTORY. WHEN THEY FAIL, THE DRIVER GETS A BRAKE LIGHT AND AN ABS INDICATOR LIGHT ON THE DASH. THE BRAKES STILL WORK ON THE CAR, BUT THEY DON'T WORK AS DESIGNED. IN FACT THE DRIVER GETS A FALSE SENSE OF SECURITY BECAUSE HIS CAR IS STOPPING, BUT IN A SLIPPERY SITUATION IT WILL NOT STOP AS DESIGNED. WHEN I WENT TO THE INTERNET FOR IDEAS TO FIX THE PROBLEM, I AM FINDING A LOT OF POSTINGS SAYING JUST TAKE THE BULB OUT OF THE DASH! I AM ALSO SEEING ADS ON E BAY WHERE YOU CAN SEND YOUR EBCM TO A REPAIR STATION, THEY TAKE IT

Mileage: 100,000

TL* THE OWNS A 2001 CHEVROLET ASTRO VAN. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE DRIVER'S AND PASSENGER'S SAFETY BELTS WOULD UNLATCH INDEPENDENTLY. THE VEHICLE HAD NOT BEEN REPAIRED OR DIAGNOSED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 162,732.

Mileage: 162,732

BRAKE AND ABS LIGHTS COME ON INTERMITTENTLY, I HAD THE CODE PULLED AT THE AUTO PARTS STORE, IT IS THE ELECTRONIC ABS CONTROL MODULE AND UPON GOOGLING "CHEVROLET BRAKE ABS LIGHTS" IT CAME TO MY ATTENTION THAT THEIR APPEARS TO BE THOUSANDS OF VEHICLES WITH FAULTY ABS ELECTRONIC MODULES WHICH PREVENTS THE ABS FUNCTION FROM WORKING. *TR

Mileage: 58,000

GOING TO STOP AT A SLOW SPEED ENGAGES ABS , CAUSING VAN TO NOT STOP UNLESS BREAKERS WERE SLAMMED ON HARD AND HOPS OF STOPPING! *TR

Mileage: 150,000

WHILE PULLING INTO A DRIVEWAY AT LOWSPEED I APPLIED THE BRAKES. THE ABS LIGHT CAME ON AND ALL BRAKING POWER WAS LOST. MY VEHICLE STRUCK THE ONE INFRONT OF ME. I HAVE BEEN ABLE TO DUPLICATE THIS LOW SPEED LOSS OF BRAKING. *TR

Mileage: 198,000

AFTER APPROX. ONE WEEK OF OPER. OF MY 2001 CHEVY ASTRO A FIRE OCCURRED THAT WOULD HAVE RESULTED IN A TOTAL LOSS OF THE VEHICLE AND CONTENTS IF I HAD NOT BEEN CLOSE BY. AFTER DRIVING MY VEHICLE FOR APPROX. 20 MILES AND PARKING IT MY VAN CAUGHT FIRE AFTER BEING SHUT OFF FOR 15 MINUTES. THE VEHICLES POSITIVE AND NEGATIVE BATTERY CABLES WERE RUN FROM THE BATTERY TO THE ENGINE DANGEROUSLY CLOSE TO THE STEERING LINKAGE WHERE IT PASSES THE ENGINE SUPPORT STRUCTURE. IF THE VEHICLE IS JACKED UP TO THE POINT WHERE THE TIRE IS STILL TOUCHING THE GROUND AND THE STEERING WHEEL IS TURNED HALF WAY TO THE LEFT THE PASSENGER SIDE INNER TIE ROD END IS RUBBING INTO THE POSITIVE AND NEGATIVE BATTERY CABLES WHICH ARE IN A COMMON HARNESS.IF THE SUSPENSION IS MOVING UP AND DOWN ON A BUMPY ROAD WHILE THE WHEEL IS TURNED TO THE LEFT DIRECT CONTACT BETWEEN THE STEERING LINKAGE AND THE BATTERY CABLES WILL CAUSE REPEATED DAMAGE OVER TIME RESULTING IN AN EVENTUAL FIRE.IF THIS FIRE OCCURRED WHILE ON THE HIGHWAY PE

Mileage: 174,000

TL*THE CONTACT OWNS A 2001 CHEVROLET ASTRO VAN. WHILE TRAVELING 5 MPH, THE CONTACT NOTICED THAT THE BRAKES WOULD NO LONGER ENGAGE AND THAT THE STEERING WHEEL HAD BECOME DIFFICULT TO TURN. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 160,000.

Mileage: 160,000

TL*THE CONTACT OWNS A 2001 CHEVROLET ASTRO VAN. WHILE TRAVELING 5 MPH, THE CONTACT NOTICED THAT THE BRAKES WOULD NO LONGER ENGAGE AND THAT THE STEERING WHEEL HAD BECOME DIFFICULT TO TURN. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 160,000.

Mileage: 160,000

ABS AND BRAKE LIGHT COMES ON WHILE DRIVING. *TR

Mileage: 97,000

TL* THE CONTACT OWNS A 2001 CHEVROLET ASTRO VAN. DURING BRAKE APPLICATION, THE VEHICLE WOULD STALL WITHOUT WARNING. THE VEHICLE HAS NOT BEEN DIAGNOSED. THE CURRENT AND FAILURE MILEAGES WERE 152000.

Mileage: 152,000

2001 CHEVY ASTRO VAN ABS SYSTEM . I HAVE REPLACED EVERY PART AND STILL HAVE PROBLEMS. I UNDERSTAND THAT THIS IS A CONSTANT PROBLEM OF THIS VAN. I THINK THEY SHOULD RECALL THESE VANS BEFORE SOMETHING BAD HAPPENS. *TR

Mileage: 50,000

NOTICED MY TIRE LOSING AIR AND HAVE TO FILL IT. UPON FILLING, I SAW A SPLIT IN THE TIRE AND SILVER METAL SHOWING THROUGH. THE TIRE IS SPLITTING ON THE SIDEWALL AND YET I HAVE LOTS OF TREAD LEFT ON THE TIRE. ALL THE OTHER TIRES ARE SHOWING A "RING" OF DETERIORATION AS WELL. YET THEY ALL HAVE SIGNIFICANT TREAD LEFT ON THEM. WE WERE TOLD THE TIRES WERE NEW WHEN WE PURCHASED THE VEHICLE IN FALL 2005. *TR

Mileage: 125,150

TRANSMISSION, PUT VAN IN GEAR AND SOMETIMES IT DOES NOT ENGAGE. FINALLY VEHICLE MAKES A LOUD POP AND JUMPS WHILE FOOT ON THE GAS. *TR

Mileage: 138,000

TL*THE CONTACT OWNS A 2001 CHEVROLET ASTRO. THE CONTACT STATED THAT THE EXTERIOR REAR DOOR HANDLE FAILED WITHOUT WARNING. IT WAS DIFFICULT TO OPEN THE DOOR. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION AND THEY REPLACED THE REAR DOOR HANDLE AND MECHANISM. THE FAILURE RECURRED, BUT THE VEHICLE HAS NOT BEEN REPAIRED AGAIN. THE FAILURE MILEAGE WAS 34,000 AND CURRENT MILEAGE WAS 135,000. UPDATED 02/05/09 *BF UPDATED 02/06/09. (JB

Mileage: 34,000

I WAS DRIVING DOWN ROUTE 130 AND THE CAR JUST DIED SO IT WAS TOWED APRIL 2008 AND THE FUEL PUMP WENT IN THE CAR WHICH COST 800.00 ON JULY 6,2008 I WAS ON MY WAS TO EWING TWSP AND THE CAR DIED AGAIN IT WAS TOWED AND THE FUEL PUMP WENT AGAIN IN THE CAR. *TR

Mileage: 96,000

A YEAR AND A HALF AGO THERE AS A LOSS OF POWER AND AN ENGINE MISS. A FUEL SYSTEM CLEANING IN A SHOP CLEARED THIS UP. THEN AT THE END OF DECEMBER THE VAN WOULD NO START. WE HAD IT TOWED TO OUR LOCAL MEINEKE. IT WAS DETERMINED THE SEQUENTIAL CENTRAL PORT INJECTOR HAD FAILED. THIS IS A DOCUMENTED PROBLEM FOR A DEFECTIVE PART. I WROTE A LETTER TO GM TO ASK FOR REIMBURSEMENT. THEY REFUSED BECAUSE I DID NOT GO TO A DEALERSHIP. AND MEINKE USED AN AFTER MARKET PART. *TR

Mileage: 125,281

ABS SYSTEM ACTIVATES AT SLOW SPEEDS CAUSING INCREASED STOPPING DISTANCE. THIS ISSUE IS SPORADIC, AND APPEARS TO HAPPEN MORE OFTEN IN COOL OR HUMID CLIMATE CONDITIONS. *TR

Mileage: 110,000

1) NOTICED THAT MY BRAKES WOULD "PRESSURIZE" WHEN COMING TO A STOP AS IF THE ANTI-LOCK BRAKES WERE ACTIVATING. I'VE EXPERIENCED NORMAL ACTIVATION BEFORE ON ICE, SNOW, AND LOOSE GRAVEL SO I KNEW WHAT IT WAS DOING. IT BEGAN HAPPENING A LOT SO I TOOK IT TO THE DEALER (BASIL CHEVROLET, WELLSVILLE, NY) ON 9/24/07. THEY REPLACED THE ROTORS, PADS AND TOLD ME "ROAD TEST OK...ON ROAD TEST DID EXPERIENCE ANTILOCK PROBLEM. ONLY ONCE FELT - UNABLE TO VERIFY". 2) TOOK MY VAN HOME AND WAS SEEING THE PROBLEM AS MUCH IF NOT MORE SO THAN BEFORE. WAS QUITE UPSET THAT AFTER SPENDING OVER $400 DOLLARS ON THE AUTO, I STILL DIDN'T HAVE THE PROBLEM FIXED THAT I TOOK THE VAN IN FOR. COMPLAINED ABOUT IT TO THE DEALER AND THEY SAID THEY COULD BRING IT IN TO "CLEAN THE SENSORS" FOR ME BUT COULDN'T GET ME IN UNTIL "NEXT WEEK". THE VERY NEXT DAY THE PROBLEM AROSE WHILE PARKING MY VEHICLE AT WORK. I LOST ALL BRAKING ABILITY AND SMASHED INTO THE REAR END OF A TRUCK. NO DAMAGE TO THE TRUCK AT ALL BUT EXTENSIVE DAMA

Mileage: 69,800