Total Complaints
2 filings
CHEVROLET 3500 · model year
2020 CHEVROLET 3500
2 NHTSA complaints for this specific cohort.
NHTSA overall rating
Not crash-tested
New Car Assessment Program
The 2020CHEVROLET3500 carries 2 consumer safety complaints in NHTSA's Office of Defects Investigation database for this specific model-year cohort. Within that volume, owners reported 0 crashes, 0 fires, 0 injuries, and 0 fatalities. No NCAP 5-star crash-test rating is available for this model year in the federal database.
Component-level analysis is where model-year complaints become actionable: the top complaint category for the 2020 3500 is electrical system: integrated trailer brake control with 1 filings, followed by power train (1). Concentration in one or two component groups is the classic signature of a systemic defect; a flat distribution usually reflects normal aging, warranty complaints, or isolated build-plant variability.
NHTSA currently has 57 investigation files overlapping the 2020 3500, and 2 remain open. Owners comparing this cohort against neighboring years should pair the counters above with the complaint-by-year trend on the parent model page — a spike in a single year often tracks to a platform refresh, a new transmission supplier, or an updated ECU calibration. Use the related-complaint feed below to read raw owner narratives before deciding whether any pattern here affects your specific use case.
2
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
Crashes Reported
0 reports
Source
NHTSA ODI
Federal complaints database
Complaints vs. fleet median (215)
At or below the fleet median complaint volume.
Complaints by Component
| Component | Count |
|---|---|
| ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL | 1 |
| POWER TRAIN | 1 |
Recent Complaints
20250707POWER TRAIN
The contact owns a 2020 Chevrolet Silverado 3500. The contact stated that while her husband was driving 70 MPH, the vehicle entered LIMP Mode with the check engine warning light illuminated. The contact then received an alert on the Chevrolet App stating, âEngine Transmission Code". Due to the failure, the contact's husband drove in LIMP Mode to the nearest independent mechanic and the mechanic discovered that the pressure-controlled solenoid-A was defective and needed to be replaced. The dealer was notified of the failure and the contact was informed that the part needed for the repair was on backorder. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 136,000.
Mileage: 136,000
20250624ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL
The contact owns a 2020 Chevrolet Silverado 3500. The contact stated while driving at an undisclosed speed, the service brake warning light illuminated. Additionally, the contact stated that the failure had occurred while the trailer was hitched to the vehicle. The vehicle was taken to the dealer where it was diagnosed with a failed trailer brake power module. The contact was informed that the trailer brake power module needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 65,000.
Mileage: 65,000
Compare 2020CHEVROLET3500 to Similar Vehicles
NHTSA Investigations 2 Open
EA25007Engineering AnalysisOpen
Loss of motive power due to engine failure
PE23022Preliminary EvaluationClosed
Loss of Motive Power due to the Battery Energy Control Module
PE20016Preliminary EvaluationClosed
Electric Vehicle Battery Fires
EA20002Engineering AnalysisClosed
Outboard Front Seat Belt Anchor Cable Failure
PE20011Preliminary EvaluationClosed
Fuel Line Leak
Frequently Asked Questions
How many complaints does the 2020 CHEVROLET 3500 have?▼
The 2020 CHEVROLET 3500 has 2 NHTSA complaints, 0 crashes, 0 fires, 0 injuries, and 0 deaths reported.
What are the most common problems with the 2020 CHEVROLET 3500?▼
The most-complained component for the 2020 CHEVROLET 3500 is ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL with 1 complaints. Other frequently reported areas include POWER TRAIN.
Is the 2020 CHEVROLET 3500 safe to buy?▼
Review the complaint history, crash and fire reports, safety ratings, and recall status on this page to make an informed decision. No NHTSA crash test rating is available for this model year. Compare with other model years using the links above.
Where does this data come from?▼
All complaint, recall, and safety rating data is sourced from the National Highway Traffic Safety Administration (NHTSA). Complaints are filed by vehicle owners through NHTSA's Office of Defects Investigation.
Vehicle Safety Guides
Data as of 2025. Sources: NHTSA Office of Defects Investigation (ODI) complaints database, NHTSA recall campaign API, NHTSA NCAP crash-test ratings, and NHTSA FARS for fatality cross-reference.
Read our methodology — how this data is sourced, computed, and verified.