Investigations
Vehicle Commanded Engine Shutdown
NHTSA Recall Query RQ14005 — closed, opened 2015-01-13 and involving the FORD PICKUP.
NHTSA investigation RQ14005 is a Recall Query opened on 2015-01-13 and currently closed. The subject of record is FORD PICKUP, which places this file inside the Office of Defects Investigation queue for FORD. Latest activity on this investigation was logged on 2016-03-15 — NHTSA updates that field whenever an Information Request goes out, a supplement is filed, or a status change is recorded in the public docket.
A Recall Query like RQ14005 evaluates whether a previously issued recall is actually fixing the problem. NHTSA opens an RQ when owners continue to report the original defect after the recall remedy is installed, or when completion rates fall short of the agency's expectations for that risk tier.
Investigators summarized the matter as follows: "The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of "Ambu..." Investigations are the early-warning layer of the federal auto-safety system, sitting upstream of formal recalls and defect orders. Whether this one closes without action or escalates into an Engineering Analysis, the full history stays in the ODI archive so researchers, litigators, and buyers can pull the paper trail at any time. Related FORD files, listed below, give context on whether this is an isolated concern or part of a broader pattern across the brand.
Investigation Summary
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of "Ambulance Package" vehicles and ODI received complaints of pickup trucks and "Fire Engine Prep Package" vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a "Stop Safely Now" (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute "cool down" period. Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to "Ambulance Package" and "Fire Engine Prep Package" vehicles where commanded shutdown could impact emergenc
About This Investigation Type
A Recall Query (RQ) evaluates the effectiveness of a previously issued recall. NHTSA opens an RQ when consumer complaints suggest that a recall remedy may not be adequately addressing the safety issue, or when the recall completion rate appears insufficient.
Other FORD Investigations
Unintended Transmission Downshift and Rear Wheel Lock-up
Timing Belt Failure
Underbody shields detachment
B-Pillar Trim Detachment
Unintended Transmission Downshift and Rear Wheel Lock-up
Data from NHTSA Office of Defects Investigation. Cross-references: NHTSA recall campaign API and NHTSA FARS where fatality records overlap. PlainCars does not rate or recommend vehicles. Learn more.
Read our methodology — how this data is sourced, computed, and verified.