Investigations
Loss of steering control
NHTSA Preliminary Evaluation PE23014 — closed, opened 2023-07-28 and involving the TESLA MODEL 3.
NHTSA investigation PE23014 is a Preliminary Evaluation opened on 2023-07-28 and currently closed. The subject of record is TESLA MODEL 3, which places this file inside the Office of Defects Investigation queue for TESLA. Latest activity on this investigation was logged on 2024-02-05 — NHTSA updates that field whenever an Information Request goes out, a supplement is filed, or a status change is recorded in the public docket.
A Preliminary Evaluation like PE23014 is the entry point of the federal defect-investigation process. NHTSA engineers scan complaint databases, field reports, and manufacturer data to decide whether an Engineering Analysis is warranted, whether a voluntary recall is already sufficient, or whether the pattern does not rise to a defect finding.
Investigators summarized the matter as follows: "On July 28, 2023, The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23-014) after receiving 12 Vehicle Owner Questionnaires (VOQs) reporting loss of steering control in model years (MY) 2023 Te..." Investigations are the early-warning layer of the federal auto-safety system, sitting upstream of formal recalls and defect orders. Whether this one closes without action or escalates into an Engineering Analysis, the full history stays in the ODI archive so researchers, litigators, and buyers can pull the paper trail at any time. Related TESLA files, listed below, give context on whether this is an isolated concern or part of a broader pattern across the brand.
Investigation Summary
On July 28, 2023, The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23-014) after receiving 12 Vehicle Owner Questionnaires (VOQs) reporting loss of steering control in model years (MY) 2023 Tesla Model 3 and Y vehicles. During PE23-014, ODI interviewed complainants, sent an Information Request (IR) letter to Tesla, and convened technical meetings with Tesla that included a joint inspection of a crashed vehicle. The investigation identified 2,388 total complaints regarding the alleged defect, including 124 complaints through VOQs and 2,264 complaints through manufacturer data. ODI is associating 1 crash to this investigation (11544655), where a driver was unable to complete a right hand turn in the intersection and hit a vehicle. This vehicle was subject to a joint inspection by ODI and Tesla. The steering rack was recovered by ODI with the consumer’s permission. ODI’s interviews of allegations supplied to the agency, in the form of VOQs, identified patterns of the incoming complaint traffic. Complaints allege an inability to turn the steering wheel, while other complaints allege an increase in required effort to turn the steering wheel. These conditions were reported to occur during the drive cycle as well as at start-up. Approximately one-third of complaints with a reported speed occurred at vehicle start-up or speeds less than 5 mph. Interviews with failures reported at speeds over 5 mph, half reported an inability to turn the steering wheel. A majority of complaints with a reported speed reported between 5 mph and 35 mph with approximately 1 in 10 occurring on open roads at speeds 35 mph and over. The highest reported speed regarding an alleged inability to turn the steering wheel is 75 mph. A majority of allegations reported seeing a warning message, “Steering assist reduced”, either before, during or after the loss of steering control. A portion of drivers described their steering begin to feel “notchy” or “clicky” either prior to or
About This Investigation Type
A Preliminary Evaluation (PE) is the first phase of NHTSA's investigation process. It is opened when the agency identifies a potential safety defect pattern, usually triggered by consumer complaints, manufacturer reports, or field monitoring. During a PE, NHTSA gathers information to determine whether a formal engineering analysis is warranted.
Other TESLA Investigations
Emergency egress controls are not readily accessible and clearly identifiable.
Traffic safety violations while Full Self Driving ("FSD") is engaged
Electronic door handles become inoperative
Compliance with Standing General Order 2021-01 Reporting Requirements
FSD Collisions in Reduced Roadway Visibility Conditions
Data from NHTSA Office of Defects Investigation. Cross-references: NHTSA recall campaign API and NHTSA FARS where fatality records overlap. PlainCars does not rate or recommend vehicles. Learn more.
Read our methodology — how this data is sourced, computed, and verified.