2011 FORD FUSION — Complaint #1939784
Open-data reference.
NHTSA Complaint about WHEELS:LUGS/NUTS/BOLTS/STUDS filed October 31, 2023
NHTSA complaint #1939784 (ODI reference 11552835) concerns a 2011 FORD FUSION and was filed on October 31, 2023. The owner reports the failure occurred on May 1, 2021. The report was geocoded to Illinois based on the filer's self-reported location. The affected component is categorized as wheels:lugs/nuts/bolts/studs, one of NHTSA's standardized taxonomy codes used to group defect patterns across make, model, and year.
The filer flagged the following severity indicators: crash: no, fire: no, injuries: 0, fatalities: 0. No crash, fire, or fatality was associated with this report, which places it in the early-warning stream rather than the priority-review stream. Because a VIN was supplied, this complaint is tied to a specific vehicle and not just a model-year cohort.
Individual complaints are consumer-submitted and unverified by NHTSA engineers — the agency's role at this stage is to collect, index, and make them searchable. What matters for federal action is the pattern: when many owners of the same FORD FUSION cohort independently describe similar wheels:lugs/nuts/bolts/studs failures, defect investigators have grounds to open a PE and request manufacturer data. Related filings for the same vehicle and component appear below, and the detail page for the full 2011 FORD FUSION shows the complete component-level complaint distribution alongside any active investigations or recalls.
Complaint Description
The contact owns a 2011 Ford Fusion. The contact stated that on five separate occasions while driving at various speeds, the vehicle began shaking uncontrollably. The contact steered to the side of the road and observed the front passengerâs side lug nuts had snapped. The vehicle was taken to a tire repair facility where it was determined that the post, rim, and tire needed to be replaced. The vehicle was repaired, but the failure persisted. The manufacturer was notified of the failure. The failure mileage was unknown.
Complaint Details
| NHTSA Complaint ID | 1939784 |
| ODI Number | 11552835 |
| Date Filed | October 31, 2023 |
| Failure Date | May 1, 2021 |
| VIN | 3FAHP0HA8BR |
Similar WHEELS:LUGS/NUTS/BOLTS/STUDS Complaints for 2011 FORD FUSION
The contact owns a 2011 Ford Fusion. The contact stated that while operating the vehicle, the message "Power Steering Sensor Fault" was displayed, and the steering wheel became difficult to turn in ei
The contact owns a 2011 Ford Fusion. The contact stated while driving 25 MPH, the front driver's side wheel lug nuts fractured, causing the wheel to detach and the vehicle to shudder. The contact dece
The contact owns a 2011 Ford Fusion. The contact stated that seventeen lug nuts had fractured and detached from the vehicle. There were no warning lights illuminated. The local dealer was not contacte
Ford uses aluminum lug nuts posing a safety risk to everyone that has a car with them. I am stuck with a flat tire on my car and no money to fix Ford's decision to use unsafe lugnuts that just strip a
TL* THE CONTACT OWNS A 2011 FORD FUSION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH NEEDING THE WHEEL STUDS TO BE REPLACED. THE VEHICLE WAS REPAIRED. UPON INVESTIGATI
Source: NHTSA Vehicle Complaints Database. Component taxonomy and severity codes are standardized by NHTSA Office of Defects Investigation.
Read our methodology — how this data is sourced, computed, and verified.