2015 RAM 1500 — Complaint #1681004
Open-data reference.
NHTSA Complaint about ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE) filed July 31, 2020
NHTSA complaint #1681004 (ODI reference 11342477) concerns a 2015 RAM 1500 and was filed on July 31, 2020. The owner reports the failure occurred on May 14, 2020. The vehicle had 70,000 miles on the odometer at the time of the incident. The report was geocoded to Massachusetts based on the filer's self-reported location. The affected component is categorized as engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve), one of NHTSA's standardized taxonomy codes used to group defect patterns across make, model, and year.
The filer flagged the following severity indicators: crash: no, fire: yes, injuries: 0, fatalities: 0. A complaint that flags a crash, fire, or fatality is escalated on NHTSA's internal review queue and factors more heavily into any Preliminary Evaluation decision on this make and model. Because a VIN was supplied, this complaint is tied to a specific vehicle and not just a model-year cohort.
Individual complaints are consumer-submitted and unverified by NHTSA engineers — the agency's role at this stage is to collect, index, and make them searchable. What matters for federal action is the pattern: when many owners of the same RAM 1500 cohort independently describe similar engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve) failures, defect investigators have grounds to open a PE and request manufacturer data. Related filings for the same vehicle and component appear below, and the detail page for the full 2015 RAM 1500 shows the complete component-level complaint distribution alongside any active investigations or recalls.
Complaint Description
VEHICLE HAS MORE THAN ONE RECALL. ONLY ONE RECALL IS STATED HERE.VEHICLE DOES NOT GO OVER 40 MPH IN MOTION. VEHICLE HAS HAD TWO FIRES RELEVANT TO THE RECALL STATED WHILE IN MOTION. RESOLUTION TO REPLACE LEMON VEHICLE IS NOT BEING MET. THIS VEHICLE IS A SERIOUS SAFETY CONCERN AND NEEDS TO BE REVIEWED IMMEDIATELY TO ASSIST IN THE RECOGNITION OF MORE APPLICABLE RECALLS NOT PREVIOUSLY INVESTIGATED.
Complaint Details
| NHTSA Complaint ID | 1681004 |
| ODI Number | 11342477 |
| Date Filed | July 31, 2020 |
| Failure Date | May 14, 2020 |
| VIN | 1C6RR7LM9FS |
Similar ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE) Complaints for 2015 RAM 1500
The contact owns a 2015 Ram 1500. The contact stated while driving at an undisclosed speed, the vehicle inadvertently lost motive power, after which the contact became aware that the vehicle had gone
TL* THE CONTACT OWNS A 2015 RAM 1500. THE CONTACT STATED THAT WHILE DRIVING, THE VEHICLE STARTED TO RUN ROUGH AS SMOKE WAS EMITTED THROUGH THE VENTS. THE CONTACT WAS ABLE TO STOP IN A PARKING LOT AND
TL* THE CONTACT OWNS A 2015 RAM 1500. WHILE DRIVING 60 MPH, THE VEHICLE STALLED AND CAUGHT ON FIRE. THE CONTACT OPENED THE HOOD AND FLAMES WERE SEEN NEAR THE REAR OF THE ENGINE COMPARTMENT. THE CONTA
Source: NHTSA Vehicle Complaints Database. Component taxonomy and severity codes are standardized by NHTSA Office of Defects Investigation.
Read our methodology — how this data is sourced, computed, and verified.