Suzuki GSX-R750 - NHTSA record changes

New NHTSA complaint: ENGINE

Thu, 18 Aug 2022 00:00:00 GMT

The contact owns a 2007 Suzuki GSX-R750. The contact stated while riding approximately 60 MPH, the motorcycle seized with both wheels unable to operate as needed. There were no warning lights illuminated. The contact turned off and restarted the motorcycle. The contact changed the brakes, and brake fluid; however, the failure reoccurred. The motorcycle was not diagnosed or repaired. The manufactur

New NHTSA complaint: ELECTRICAL SYSTEM

Thu, 06 Aug 2020 00:00:00 GMT

THE FIRST TIME I HAD MY PROBLEM I WAS IN MOTION WHEN THE RECTIFIER BURNED UP AND THE RECTIFIER AND STATOR WENT OUT I PUSHED IT HOME, 2 YEARS AFTER THAT IN THE SPRING I PUT MY BATTERY BACK IN IT FIRED IT UP AND POOF THE RECTIFIER BURNS UP AND NOW 8/6/20 BIKE QUIT RUNNING BOUGHT A NEW BATTERY AND STILL WONT START I CHECKED THE RECTIFIER AND IT LOOKS GOOD DON'T LOOK OR SMELL FRIED AND THAT MEANS THE

New NHTSA complaint: ELECTRONIC STABILITY CONTROL (ESC)

Thu, 31 Jan 2019 00:00:00 GMT

TAKATA RECALL I KEEP GOING THROUGH RECTIFIERS, STATORS, FUSES, FUEL PUMPS, WIRING, BATTERY, STARTER AND EVEN A A USED ECU PLUS A FEW OTHER THINGS ALL COMING BACK TO THE RECTIFIER MISSING EVERYTHING UP A FEW TIMES A YEAR AND NOW AGAIN I'M GONNA HAVE TO SEND MY BIKE BACK OUT AND PAY FOR EVERYTHING TO GET DONE AGAIN I'M KINDA MAD THAT I BOUGHT IT INSTEAD OF THAT 2000 HAYABUSA LIKE I WAS GOING TO.

New NHTSA complaint: ELECTRICAL SYSTEM

Thu, 31 Jan 2019 00:00:00 GMT

New NHTSA complaint: FUEL/PROPULSION SYSTEM

Thu, 31 Jan 2019 00:00:00 GMT

New NHTSA complaint: ENGINE

Mon, 23 Apr 2018 00:00:00 GMT

TL* THE CONTACT OWNS A 2006 SUZUKI GSX-R750. WHILE DRIVING 50 MPH DOWN A MOUNTAINSIDE, THE VEHICLE'S THROTTLE DID NOT MOVE, THE SPEED DECREASED TO ZERO, AND THE MOTORCYCLE SEIZED. THE CONTACT HAD THE MOTORCYCLE TOWED TO HIS RESIDENCE. THE LOCAL DEALER AND THE MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

New NHTSA complaint: POWER TRAIN

Mon, 23 Apr 2018 00:00:00 GMT

New NHTSA complaint: ELECTRICAL SYSTEM

Mon, 11 Jul 2016 00:00:00 GMT

I WAS GOING 70 DOWN THE HIGHWAY WHEN MY BIKE SHUT OFF. LOOKED AT THE 30AMP FUSE UNDER THE SEAT AND IT WAS BLOWN. REPLACED IT WITH THE SPARE AND IT IMMEDIATELY BLEW. TRAILERED MY BIKE BACK TO MY HOUSE AND FOUND THE REGULARTOR/RECTIFIER SPARKING. THIS IS A HUGE ISSUE AND SHOULD BE A RECALL. BIKE WAS DRIVEN NORMALLY WITH NO RACING/SPEEDS OVER 80.

New NHTSA complaint: ELECTRICAL SYSTEM

Sat, 14 May 2016 00:00:00 GMT

I WAS AT A STOPLIGHT WHEN THE VEHICLE NEXT TO ME TOLD ME THAT MY BIKE WAS ON FIRE. I WAS UNAWARE PRIOR TO THE DRIVER OF THE VEHICLE NEXT TO ME TELLING ME. I COULD NOT DIRECTLY SEE THE FLAME WHILE UPRIGHT ON THE BIKE, BUT I WAS ABLE TO LEAN OVER TO MY LEFT SIDE TO SEE A FLAME UNDERNEATH THE GAS TANK. I PULLED OVER IMMEDIATELY BUT UNFORTUNATELY COULD NOT PUT THE FLAME OUT AS IT WAS NOT REACHABLE B

New NHTSA complaint: ELECTRICAL SYSTEM

Wed, 11 May 2016 00:00:00 GMT

I HAVE OWNED THE BIKE FOR LESS THAN A YEAR NOW AND 3 TIMES THE REGULATOR HAS FRIED IN THE BIKE. I HAVE A NEW STATOR AND BATTERY IN THE BIKE ALL CHARGING FINE. LUCKILY ALL THE TIMES WHEN IT HAS STOPPED WORKING I WAS STOPPED. BUT ONCE I WAS 21ST A BUSY INTERSECTION AND THANKFULLY A DRIVER OF A CAR LET ME WALK IT TO THE SIDE WALK. IN AFRAID THIS IS GOING TO HAPPEN WHILE I'M GOING DOWN THE INTERSTATE

New NHTSA recall: ELECTRICAL SYSTEM

Tue, 19 Jan 2016 00:00:00 GMT

Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2008-2012 AN400, AN400A, DL1000, GSX1300R, 2008-2009 GSF1250S and GSF1250SA, 2008 GSX1300BK and GSX1300BKA, 2008-2010 GSX650F, GSX-R600, GSX-R750, VLR1800, VLR1800T, and 2009-2010 SFV650 and VZ1500 motorcycles. Due to a problem with the circuit board for the regulator/rectifier power module, the motorcycle may not sufficiently

New NHTSA complaint: ENGINE

Tue, 22 Sep 2015 00:00:00 GMT

TL* THE CONTACT OWNS A 2014 SUZUKI GSX-R750. WHILE RIDING AT 65 MPH, SMOKE APPEARED FROM THE MOTORCYCLE. THE CONTACT NOTICED OIL LEAKING FROM THE ENGINE ONTO THE REAR TIRE. UPON INSPECTING THE MOTORCYCLE, THE CONTACT NOTICED THAT THE CONNECTING ROD PUNCHED THROUGH THE ENGINE. THE MOTORCYCLE WAS TAKEN TO THE DEALER TO BE INSPECTED. THE CONTACT STATED THAT THE DEALER TOOK PICTURES OF THE MOTORCYCLE

New NHTSA recall: POWER TRAIN:MANUAL TRANSMISSION

Tue, 07 Oct 2014 00:00:00 GMT

Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2011-2014 GSX-R750 and 2009-2014 GSX-R1000 motorcycles. If a gear is missed while upshifting, the strain applied to the drive chain after the next shift may cause the rear axle to move, damaging the left-side drive chain adjuster.

New NHTSA recall: SERVICE BRAKES

Fri, 18 Oct 2013 00:00:00 GMT

Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2004-2013 GSX-R600 and GSX-R750, and model year 2005-2013 GSX-R1000 motorcycles. In combination with older brake fluid, corrosion of the brake piston inside of the front brake master cylinder generates gas that may result in a reduction of fluid pressure transmission to the front brake.

New NHTSA recall: SERVICE BRAKES

Fri, 18 Oct 2013 00:00:00 GMT

New NHTSA recall: SERVICE BRAKES

Fri, 18 Oct 2013 00:00:00 GMT

New NHTSA recall: SERVICE BRAKES

Fri, 18 Oct 2013 00:00:00 GMT

New NHTSA recall: SERVICE BRAKES

Fri, 18 Oct 2013 00:00:00 GMT

New NHTSA complaint: ENGINE

Mon, 02 Jul 2012 00:00:00 GMT

FAILURE CAN OCCUR RANDOMLY AND WILL RESULT IN LOSS OF POWER TO THE MOTOR UNDER ACCELERATION. THE PROBLEM AFFECTS THE 2004-2005 MODEL YEARS. SPECIFICALLY THE SECONDARY THROTTLE VALVE ACTUATOR (STVA) CAN FAIL AND RESULT IN LOSS OF ENGINE POWER. A FI (FUEL INJECTION) CODE DISPLAYS ON THE DASH. ONCE YOU ACCESS DEALER MODE, THE DISPLAY CODE IS C-28. THIS IS DUE TO FAULTY SOLDER CONN

New NHTSA complaint: SERVICE BRAKES

Tue, 15 May 2012 00:00:00 GMT

WHILE TRAVELING APPX 30 MPH AND APPROACHING A TURN I APPLIED THE BRAKES FRONT AND REAR. THE FRONT BRAKE FAILED. I EXAMINED THE CABLE, MASTER CYLINDER AND BRAKE LINE AND FOUND NO PROBLEMS OR LEAKS. MASTER CYLINDER WAS FULL. I CONTACTED THE LOCAL SUZUKI MCY DEALER TO SEE IF THEY HAD SIMILAR PROBLEMS AND WAS ADVISED THEY HAVE. THEY BELIEVE A COMPLETE BRAKE FLUID FLUSH AND WRAPPING THE BLEEDER SCREW W

New NHTSA complaint: VEHICLE SPEED CONTROL

Sat, 24 Mar 2012 00:00:00 GMT

ABRUPT ON/OFF THROTTLE CAN CAUSE SUDDEN AND UNEXPECTED RAPID DECELERATION AND ACCELERATION, DESTABILIZING THE VEHICLE POTENTIALLY LEADING TO LOSS OF CONTROL AND A CRASH. THE PROBLEM SEEMS TO OCCUR AT LOWER ENGINE RPM'S (4,000-6,000 RPM) AND SEEMS MOST PREVALENT AT HIGH ENGINE TEMPERATURES (205+ DEGREES) AND ESPECIALLY WHEN THE VEHICLE IS TURNED ON AND STARTED WHILE AT HIGHER TEMPERATURES. THIS

New NHTSA complaint: FUEL SYSTEM, GASOLINE

Sat, 24 Mar 2012 00:00:00 GMT

New NHTSA complaint: ELECTRICAL SYSTEM

Sat, 24 Mar 2012 00:00:00 GMT

New NHTSA complaint: ELECTRICAL SYSTEM

Sat, 03 Dec 2011 00:00:00 GMT

MOTORCYCLE CUT OFF, AND LOST POWER WHILE DRIVING. I WAS NOT ABLE TO START THE MOTORCYCLE AGAIN AFTER THAT. THERE IS A RECALL ON THE VOLTAGE REGULATOR FOR THE SAME YEAR (2007) BUT FOR THE GSXR 1000. *TR

New NHTSA complaint: EQUIPMENT

Thu, 05 May 2011 00:00:00 GMT

MY SON WAS KILLED IN A MOTORCYCLE ACCIDENT ON JANUARY 14, 2010 ON HIS 2005 SUZUKI GSX-R750. *TR

New NHTSA recall: ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

Wed, 23 Feb 2011 00:00:00 GMT

SUZUKI IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 MOTORCYCLES MANUFACTURED FROM JULY 2007 THROUGH SEPTEMBER 2009, EQUIPPED WITH REGULATOR/RECTIFIER ASSEMBLIES, SUZUKI PART NUMBERS 32800-41F11, 32800-15H10, 32800-05H11, 32800-41G10, 32800-15H00, 32800-18H00, 32800-05G10, 32800-10G10, 32800-05H20, OR 32800-06G01. SOME REGULATOR/RECTIFIER ASSEMBLIES WERE PRODUCED WITH INSUFFICIENT ADHESION BE

New NHTSA complaint: FUEL SYSTEM, GASOLINE

Wed, 26 Aug 2009 00:00:00 GMT

I OWN A 2005 SUZUKI GSX-R 750CC SPORTBIKE MOTORCYCLE AND IM HAVING ISSUES WITH THE CHECK ENGINE LIGHT GOING ON. I TOOK IT TO THE DEALER WHO DIAGNOSED A C28 ERROR WHICH IS A FAULTY THROTTLE VALVE ACTUATOR. APPARENTLY THIS IS AN ISSUE WITH MANY 04-05 SUZUKI GSX-R OWNERS. THE ENTIRE THROTTLE BODY MUST BE REPLACED FOR WHAT MANY PEOPLE BELIEVE TO BE A DEFECT IN THE DESIGN OF THE ACTUATOR. SOMEHOW THE S

New NHTSA complaint: ENGINE AND ENGINE COOLING:ENGINE

Wed, 29 Jul 2009 00:00:00 GMT

GENTLEMEN I OWN A 2006 SUZUKI GSXR 750 SPORT BIKE AND TO PUT IT LIGHTLY, I AM SCARED TO RIDE IT. THE PROBLEM IS THAT THE BIKE WHILE RIDING AT AN AVERAGE SPEED AT AROUND 4000-6000 RPM'S, WITH JUST A MINUTE CHANGE IN ACCELERATION THE BIKE ACCELERATES AND DECELERATES UNCONTROLLABLY. THIS IS A GREAT PROBLEM WHICH CAN LEAD TO LOSS OF CONTROL AND POTENTIALLY LEAD TO AN ACCIDENT. I HAVE TAKEN THE MOTORCY

New NHTSA complaint: ENGINE AND ENGINE COOLING:ENGINE

Mon, 20 Jul 2009 00:00:00 GMT

AT LOW RPM'S OR OPENING THROTTLE FROM STOP, THE THROTTLE ABRUPTLY ENGAGES AND JERKS ME FORWARD IN AN UNCONTROLLED MANNER. THIS COULD BE SERIOUS IF I WERE TO LOOSE CONTROL OR TAKE MY ATTENTION AWAY FROM THE ROAD OR VEHICLES IN FRONT OF ME. *TR

New NHTSA complaint: FUEL SYSTEM, GASOLINE

Tue, 07 Jul 2009 00:00:00 GMT

MY GAS TANK ON A 2006 GSXR 750 RUSTED OUT IN UNDER 3 YEARS. GAS WAS POURING OUT OF THE BOTTOM OF THE TANK WHERE 3 HOLES WERE SUBSEQUENTLY DISCOVERED. APPARENTLY, RUSTED OUT GAS TANK IS NOT COVERED UNDER WARRANTY ON A 3 YEAR OLD BIKE. IF THE GAS TANK CAN'T HANDLE THE REGULAR WATER CONTENT OF THE GAS THAT IS POURED INTO IT, IT IS AN UNSAFE TANK. *TR